Professional Documents
Culture Documents
Paramet
Value
er
000110
01
311 (4800
Baud
rate)
340 2
341 2
TV
0
Check
Punch
1
code
Input
0
unit
Input
1
device 1
Input
1
device 2
To set the CNC up for drip feed:
Set "Tape mode" on.
Dripfeed facility on the Fanuc must be enabled.
Send the program from the computer, then press Cycle Start on the
Fanuc.
To pause dripfeed, turn the Feedrate override to 0%.
Common Settings
Name Send
Fanuc Settings
6 and 6M
Header
Baudrate String CNC setting)
4800 (or to match
Data Trailer
bits String 7
Stop bits End
2 of Line Sequence
ParityRecognize custom
Even EOL
FlowReplace
control Xon/Xoff
Xon Char. 17
Xoff char. 19 Checked. This
Port as available control requires a
"%" at the
Check "%" character
beginning and
end of your
Receive Settings
programs.
Header String
Skip empty lines user's choice
Trailer String
Skip line numbers user's choice
End of Line Sequence
Skip non printable bytes user's choice
Recognize
check "(...)" if
custom
SkipEOL
comments
required
Folder in which
you store this
Default folder
machine's
programs
Start transfer delay user's choice
Replace
13,10
(checked)
Check "%" Checked. This control requires a "%" at
character the beginning and end of your programs.
Skip empty
user's choice
lines
Skip line
user's choice
numbers
Skip non
printable user's choice
bytes
Skip
check "(...)" if required
comments
Default Folder in which you store this machine's
folder programs
Start transfer
user's choice
delay
Cable Pin Out for RS232 COMM port
Sometimes file transfer will not run, even if all the settings are
correct. Go to this page for solutions.