Machining allowances
In order to make sure that all surface imperfections such
‘as decarburization, carburization, cracking, surface
‘oxidation or scaling can be removed, itis necessary to
provide al rolled oF forged bar with sufficient machining
allowances on the finished size
Ordering exampl
Finished size: 100 mm diameter
Machining allowance: 6 mm
Nominal size 108 mm with admissible
tolerance of + 1.5/0.3 mm, i.e.
‘maximum actual size = 107.5 mm
minimum actual size = 105.7 mm
‘The machining allowance takes into account the
‘admissible tolerance which guarantees that after removal
ofa uniformly thick layer of material on all sides from the
‘ough size, the finished size will definitely be free of
‘material or production dependent defects, even in case of
minus deviations from nominal size.
Premachined components also require small machining
allowances whereas finish machined products require no
‘machining allowances (except when production is
followed by a subsequent heat treatment in which case
an allowance for grinding and polishing should be
provided)
For detailed information on machining allowances and
‘admissible tolerances of BOHLER bar (rolled of forged
bar; 180 ECOMAX = premachined, preground bar;
Precision ground flats) please refer to our brochure
No. STa91