Professional Documents
Culture Documents
SB
8.50
Ø 219.0±0.10
Ø7.9 (x8)
Ø4.3 (x8)
Ø 234.0±0.45
Ø 120.0
Ø 205.0
80.7
92.4
Specs :
FEATURES
Nominal Impedance 8W Free air resonance, Fs 25 Hz
· Soft low damping rubber surround for improved
transient response DC resistance, Re 5.6 W Sensitivity (2.83 V / 1 m) 87.5 dB
· Geometrically reinforced ceramic cone for improved Voice coil inductance, Le 0.60 mH Mechanical Q-factor, Qms 5.41
break-up control
Effective piston area, Sd 216 cm2 Electrical Q-factor, Qes 0.44
· Shorting ring in motor system for reduced distortion
· Vented pole piece for reduced compression Voice coil diameter 45.5 mm Total Q-factor, Qts 0.40
· Vented cast aluminium chassis for Voice coil height 19 mm Moving mass incl.air, Mms 31 g
optimum strength and low compression Air gap height 6 mm Force factor, Bl 7.9 Tm
· Shallow design Linear coil travel (p-p) 13 mm Equivalent volume, Vas 87 liters
· Non-conducting fibre glass voice coil former for
minimum damping Magnetic flux density 0.86 T Compliance, Cms 1.31 mm/N
· CCAW voice coil for reduced moving mass Magnet weight 0.8 kg Mechanical loss, Rms 0.9 kg/s
· Long life silver lead wires Net weight 2.7 kg Rated power handling* 50 W
* IEC 268-5, T/S parameters measured on drive units that are broken in.
100 160
95 147
90 133
85 120
80 107
75 93
Ohm
70 80
dB
65 67
60 53
55 40
50 27
45 13
40 0
10 20 50 100 200 500 1k 2k 5k 10k 20kHz
(IEC baffle, mic distance 31.6 cm, SPL shown for 2.83 V / 1 m)
------ (Blue) : on axis ------ (Green) : 30° off-axis ------ ( Red ) : 60° off-axis