Professional Documents
Culture Documents
htm
ISO konektor
ISO konektor
B 1 Right Rear +
B 2 Right Rear -
ISO
B 3 Right Front +
Connector
B B 4 Right Front -
B 5 Left Front +
B 6 Left Front -
SPEAKERS
B 7 Left Rear +
B 8 Left Rear -
A 1 GALA
Geschwindigkeitsabhängige
Lautstärkeranpassung or
SCV speed-dependent
volume control.
A 2 Mute from Cell-Phone
A 3 RFLS
ISO
Ruckfahrtlichtschalter - the
Connector
reversing light switch.
A
A 4 Memory Power
(12V direct from Battery)
ISO connectors back of car radio POWER A 5 Power for Electric
Antenna
A 6 Dial-light illumination
(car side light circuit)
A 7 +12V Main Power
(Switched via Ignition key)
A 8 Ground (Chassis)
Note, on modern Volkswagen Group cars and some older vehicles (such as the Peugeot 106 or Vauxhall
Astra) the +12V Ignition and Battery positions are reversed.
1 de 6 05-03-2015 03:50
ISO konektor autoradio http://www.tehnomagazin.com/Auto-radio-car-connector/ISO-konektor.htm
Attention:
The connector wiring may vary depending on the car manufacturer, even when ISO connectors are used. We
recommend to check the car’s wiring provision before connecting the car stereo.
Please pay particular attention to pin 5, where a misconnection might cause damage to the car or radio.
Take special care when installing into ’98 or later VW/Audi/Skoda/Seat models as there may be a 12 V
connection on Pin 5, which could damage the car stereo or into Ford from ’97 or later , with an ISO connector,
on which damage to the car’s microcomputers is possible if misconnected.
Use of ISO connector adapters available on the market may facilitate installation.
Power (A)
The first connector A is always present, is usually black in colour, and contains pins for power-
supply, off/on (typically controlled by ignition key), optional control for a motorised antenna and
so on.
On some cars the +12V Ignition and Battery positions are reversed, such as later Volkswagen
group cars, Peugeot 106, Vauxhall Astra, Citroën C3.
Pin 1 is optional; used for speed dependent volume control and possibly navigation.
Pin 2 is optional; used for reversing lamp signal on Becker radios with navigation.
Pin 3 is also used for phone mute (Becker)
Pin 6 is optional; used for vehicle instrument illumination
Loudspeaker (B)
The second connector B is for connecting four loudspeakers, front, rear, left and right, and is
usually brown in colour.
Miscellaneous (C)
The connector C is optional. Some times, it appears as one 20-pin connector, often red in colour,
or it may be divided into three separate connectors which may be hooked together, in which case
C1 is usually yellow, C2 is usually green which C3 is usually blue in colour. The contact spacing is
narrower than the other connectors, so the C connector is sometimes referred to as mini-ISO.
Note: ISO 10487 only defines the physical attributes of the connectors, not the pin/signal designations, which
are manufacturer-defined. The example above is oriented towards VW vehicles only.
ISO 10487 je standardi 8-pinski konektor koji se koristi kod autoradio uređaja (head unit). Ima kontakte za
napajanje, off/on ( kontroliran ključem za paljenje), za zvučnike i automatsku antenu.
Ovaj pin se koristi u nekim autoradio uređajima za automatsko pojačanje glasnoće zvuka. Potreban mu
je izlaz sa senzora brzine. Napomena: ako mjerač brzine prestane raditi kad je autoradio spojen, tada je
taj pin vjerojatno uzemljen jer radio vjerojatno koristi taj pin za neku drugu funkciju osim za GALA.
PIN 2 - Mute control – ovaj pin služi za stišavanje zvuka autoradia, uzemljuje ga neka druga vanjska
komponenta npr. mobilni telefon koji je spojen na autoradio.
2 de 6 05-03-2015 03:50
ISO konektor autoradio http://www.tehnomagazin.com/Auto-radio-car-connector/ISO-konektor.htm
PIN 3 – RFLS Ruckfahrtlichtschalter - the reversing light switch. Satelitska navigacija koristi ovaj signal,
GALA signal (pin 1) i unutarnji laserski žiroskop za izračunavanje u odsustvu satelitskog signala. +12V
ulaz na autoradiu s uključenim kontaktom na bravi za paljenje i auto je u brzini za kretanje unazad.
PIN 4 – stalnih +12V s akumulatora - napajanje za autoradio. Povezivanjem autoradija direktno na
akumulator, nije potrebno imati ključ u bravi za paljenje. Neki moderni autoradio uređaji imaju
automatsko isključivanje. Na ovaj priključak spaja se memorija autoradia.
PIN 5 – Automatska antena – izlaz iz autoradia +12V maksimum 150 – 300mA za napajanje
automatske ili elektronske antene. Ako postoji mora se spojiti iako antena nije automatska. On također
upravlja zvučnim signalom koji upozorava da su vrata otvorena.
PIN 6 – osvjetljenje +12V ulaz na autoradiju kad su svjetla upaljena. Kod nekih autoradia on zapravo
osvjetljuje display – kod drugih može zatamniti osvjetljenje, zamjenjuje odnos crno na bijelo ili čak
mijenja boju od zelene do narančaste. Ako tabla s instrumentima u automobilu ima funkciju regulacije
osvjetljenja, taj pin treba spojiti kako bi se moglo regulirati jačina osvjetljenja. Žica od osvjetljenja
upaljača za cigarete se može za to koristiti.
PIN 7 – +12V sa ključa za paljenje kad je ključ u kontakt bravi na položaju ON ili ACC.
PIN 8 – uzemljenje, šasija, minus 12V
Konektor B se koristi samo za zvučnike. Koja žica ide na koji zvučnik može se lako utvrditi s baterijom
od 1,5V. Zvučnik će kliknuti i vidjet ćete pomicanje membrane unaprijed ili unazad. Zvučnici moraju biti
pravilno fazirani (pazite na + i – pol na zvučniku) jer u suprotnom ćete imati slab bas. Žice za zvučnik su
u paru, žica s prugom je + pol zvučnika.
C2 - remote control
Pin 7 - RXD
Pin 8 - TXD
Pin 9 - Chassis ground
Pin 10 - +12v switched - maximum 150mA
Pin 11 - Remote control in
Pin 12 - Remote control ground
C3 - CD changer
3 de 6 05-03-2015 03:50
ISO konektor autoradio http://www.tehnomagazin.com/Auto-radio-car-connector/ISO-konektor.htm
ISO konektor C
Konektor C su zapravo tri odvojena konektora koja su užlijebljena zajedno. On nije uvijek prisutan,
ponekad samo dio postoji. Obično je priključen na uređaj kojeg podržava.
After 2000, some companies began to apply the new standard connector. It has now become
almost standard because it spun off a separate division. This type of connector is listed under the
name FAKRA.
It is a connector that uses the CAN bus. Many signals are transmitted on the bus. They are:
- Information on the ignition
- Information about the lights on
- Information on speed
The next step is to transfer control information and audio signals in digital form by means of fiber
optic line. The connector FAKRA is space for two optical fibers transmitting and two receiving.
With the introduction of this type of connector antenna connectors have been changed.
Quadlock
From 2000 and onwards, manufacturers, such as BMW, Citroen, Ford, Mercedes Benz, Peugeot,
Volkswagen, Rover, Audi, Seat, Opel and Škoda have started using a 40 pin connector instead,
called the Quadlock (or Fakra, after the manufacturer).
The Quadlock connector consists of a block of 16 flat pins analogous to the two main ISO 10487
connectors. While the physical contact pins are the same, the pin allocation is not entirely the
same, and the connector housing is not compatible. In addition to the 16 pins, like ISO 10487,
there are minor connectors for optional equipment. They fit within the frame of the main
connector, and has coding so that they cannot be interchanged. Minor connector B has 12 pins for
audio output signals. Minor connector C has 12 pins for various audio sources such as
CD-changers, MP3 players.
Quadlock A
4 de 6 05-03-2015 03:50
ISO konektor autoradio http://www.tehnomagazin.com/Auto-radio-car-connector/ISO-konektor.htm
cd-changer line in
2 Speaker RF+ RFLS (wsteczny)
gnd
3 Speaker LF+ V-signal line out FL
4 - cd-changer +12V MIC OUT -
5 - K-line line out RL
6 SpeakerRF- cd-changer data out telefon in -
7 Speaker LF- BOSE pin MIC IN +
8 - cd changer line in L+ line out GND
9 CAN H cd changer line in R+ line out FR
10 CAN L cd-c +12V ster. MIC OUT +
11 mute cd-changer data in line out RR
12 masa cd-changer clock telefon in +
13 amplifier remote x x
14 DWA-GND x x
15 +12V x x
16 +SAFE x x
5 de 6 05-03-2015 03:50
ISO konektor autoradio http://www.tehnomagazin.com/Auto-radio-car-connector/ISO-konektor.htm
ISO connector Car Radio Stereo Audio Wiring Diagram Autoradio connector wire installation schematic schema
esquema de conexiones stecker konektor connecteur cable shema car stereo harness wire speaker pinout
connectors power how to install.
ISO connectorr Car radio wiring diagrams. Car radio wire diagram stereo wiring diagram gm radio wiring diagram.
Car stereo wiring diagrams car radio wiring car radio wiring colors car radio wire car radio connections wiring
diagram car radio wire colours.
ISO connector auto radio wiring diagrams install car radio. How to install car radio autoradio wiring harness stereo
installation. How to install car radio wires. Car radio install car wiring diagrams wiring harness pinout connector
diagram. Car stereo radio wiring diagram. How to wire a car radio wiring diagram for car stereo. Car stereo wiring
diagram radio installation head unit. Car radio wire colors car audio wiring free radio wiring diagrams. Radio diagram
wiring car radio car radio wiring diagrams. Free car radio wires stock diagram. Car radio wiring colour codes car
radio speakers.
6 de 6 05-03-2015 03:50