You are on page 1of 5

ECM

The ECM is located behind the drivers side kick panel.

The ECM is not interchangeable, with other Delco Remy 3C System ECM's.

A replacement ECM comes complete with a new Mem-Cal.

ECM Voltage Table

Connector `A'

Pin # Circuit and Status........................................... Voltage

A1 Fuel Pump Relay Control


Ignition On (within 2 seconds)............................ Battery Volts
Ignition ON (after 2 seconds)............................. 0 Volts
Engine Running............................................... Battery Volts

A2 Torque Converter Clutch Control Output (Auto)


Ignition ON....................................................... 0 Volts

A4 Air Conditioner Control Input


Ignition ON
Air Conditioner OFF.......................................... Battery Volts

Air Conditioner ON............................................ Low Volts

A5 Malfunction Indicator Lamp


Engine Idling
Lamp OFF....................................................... Battery Volts
Lamp ON........................................................ <1 Volts

A6 ECM Ignition Supply


Ignition ON....................................................... Battery Volts
A8 Serial Data
Ignition ON...................................................... 5 Volts

Engine Running................................................ 5 Volts

A10 Vehicle Speed Sensor Input Signal


Ignition ON...................................................... Battery Volts
Driving wheels rotating...................................... 0.6 to Battery Volts Pulses

A11 Sensor Ground


All Times.......................................................... <0.2 Volts

A12 System Ground to ALDL Connector

All Times.......................................................... <0.2 Volts

Connector `B'

Pin # Circuit and Status........................................... Voltage

B1 Permanent Battery Supply


All Times......................................................... Battery Volts

B2 Diagnostic Test
Ignition ON

Terminal not Grounded...................................... 5 Volts


Terminal Grounded........................................... <0.2 Volts

B3 Ignition Module Reference Low


Ignition ON....................................................... <0.2 Volts

B5 Ignition Module Reference High


Ignition ON....................................................... <0.2 Volts

Engine Running................................................ 0.9 Volts

B7 ATCP Module (If Fitted)


BUS Negative................................................... Serial Data

B8 Air Conditioner ON/OFF Input Circuit


Ignition ON
Air Conditioner OFF.......................................... <0.2 Volts
Air Conditioner ON............................................ Battery Volts

B10 Park Neutral Position Switch Input Circuit (Auto)


Ignition ON

Park Or Neutral Selected.................................. 0 Volts


Any Other Gear Selected.................................. Battery Volts

Connector 'C'

Pin # Circuit and Status........................................... Voltage

C1 Air Conditioner High Speed Cooling Fan Control Circuit


Engine Running
Cooling Fan OFF.............................................. Battery Volts
Cooling Fan Low Speed ON............................... Battery Volts
Cooling Fan High Speed ON.............................. Low Volts

C2 ATCP Module (If Fitted)


BUS Positive.................................................... Serial Data

C3 Idle Air Control Valve Coil "B" Low

Engine Running................................................ Voltage Pulses

C4 Idle Air Control Valve Coil "B" High


Engine Running................................................ Voltage Pulses

C5 Idle Air Control Valve Coil "A" High


Engine Running................................................ Voltage Pulses

C6 Idle Air Control Valve Coil "A" Low


Engine Running................................................ Voltage Pulses

C9 Air Conditioner Cooling Fan ON/OFF Input Circuit


Engine Running
Cooling Fan OFF.............................................. Low Volts
Cooling Fan Low Speed ON............................... Battery Volts
Cooling Fan High Speed ON.............................. Battery Volts

C10 Engine Coolant Temperature Sensor


Engine Running
Engine @ Normal Operating Temperature............ 1.5 to 2.0 Volts
C11 Manifold Air Pressure Sensor Input Signal

Ignition ON....................................................... 5 Volts


Engine Idling.................................................... 1.7 Volts

C12 Intake Air Temperature Sensor Signal Input


Engine Running
Engine @ Normal Operating Temperature........... 2.0 Volts

C13 Throttle Position Sensor Input


Ignition ON
Throttle @ Fully Closed Position........................ 0.3 to 1.3 Volts
Throttle @ Wide Open Position......................... >4.0 Volts

C14 Throttle Position Sensor / Manifold Air Pressure Sensor Voltage Supply
Ignition ON....................................................... 5 Volts

C16 Battery Supply


All Times.......................................................... Battery Volts

Connector 'D'

Pin # Circuit and Status........................................... Voltage


D1 System Ground Circuit
All Times......................................................... <0.2 Volts

D2 Sensor Ground Circuit


All Times......................................................... <0.2 Volts

D3 Injector Driver Circuit Ground


All Times......................................................... <0.2 Volts

D4 Electronic Spark Timing Output

Ignition ON....................................................... <0.2 Volts


Engine Running (EST operating)......................... 0 Volts

D5 Ignition Advance Bypass


Ignition ON....................................................... <0.2 Volts
Engine Cranking under 400 RPM........................ <0.2 Volts
Engine Running................................................ 4.6 Volts

D6 Oxygen Sensor Ground


All Times.......................................................... <0.2 Volts
D7 Oxygen Sensor Signal
Engine @ Operating Temperature
Engine speed steady @ 2500 RPM.................... 0 to 1 Volts
Switching

D10 Injector Driver Circuit Ground


All Times.......................................................... <0.2 Volts

D15 Fuel Injector Driver Circuit


Ignition ON....................................................... Battery Volts
Engine Running................................................ Voltage Pulses

D16 Fuel Injector Driver Circuit


Ignition ON....................................................... Battery Volts
Engine Running................................................ Voltage Pulses

You might also like