Professional Documents
Culture Documents
Overview
The Inventables wood clamp set is a versatile clamping system that easily adjusts to the height of your work piece.
They are very stiff, yet typically will not break your bits if they are hit while cutting.
Assembly Instructions
1. Install one threaded insert into each clamp from the back side using a 6mm allen wrench (T handle is best). The
hole has a countersink to accept the head of the insert. Place the clamp upside down on a firm surface. Install it
flush. Do not tighten it firmly or you could crack the clamp.
2. Install the carriage bolt into the threaded insert on the bottom side. It is not meant to be adjustable and not
tightened all the way.
Usage
1. Set the clamp on your work piece and adjust the carriage bolt until the clamp is level.
2. Select an appropriate length M5 mounting screw and install with a flat washer.
3. Firmly tighten the clamp.
Make More!
Did you damage one or need more? You can make your own with your router. The DXF for the part is on the product
page.
Rev: 3/11/2014 Sheet 1 of 1
https://www.inventables.com/technologies/clampset
Rev: 3/11/2014 Sheet 1 of 1