You are on page 1of 5

20.

NOTE: The left-hand high-pressure fuel supply line is tightened after


the high pressure fuel system has been bled.

Install the left-hand high-pressure fuel supply line but do not tighten
the unions at this stage.

Remove and discard the blanking caps.

21. Install the fuel injection pump belt rear cover.

Tighten to 7 Nm.

22. Raise the vehicle.


23. Install the turbocharger heat shield.

Tighten to 10 Nm.

24. Tighten to 6 Nm.

25. Attach the EGR coolant outlet tube.

Tighten to 10 Nm.
26. Install the left-hand catalytic converter.
For additional information, refer to: Catalytic Converter - 2.7L V6 - TdV6
(309-00 Exhaust System, Removal and Installation).
27. Attach the EGR coolant outlet tube.

Tighten to 10 Nm.

28. Attach the EGR coolant outlet tube.

29. Install the fuel injection pump pulley.

30. Install the retaining nut.

Using the special tool, retain the fuel injection pump pulley.

Tighten to 50 Nm.
31. Install the camshaft rear pulley.

32. Install the camshaft rear pulley retaining bolt.

Using the special tool, retain the camshaft rear pulley.

Tighten the camshaft rear pulley retaining bolt in two stages:


1. Tighten to 80 Nm.

2. Tighten a further 90°

Remove the special tool.

33. NOTE: The fuel injection pump rotates in an anti-clockwise direction


when view from the rear of the engine.

Note the direction of rotation of the fuel injection pump belt.

34. CAUTION: Do not install the new fuel injection pump belt to the
pulleys with the fuel injection pump belt tensioner installed. Failure to
follow this instruction may result in damage to the fuel injection pump
drive belt.

• NOTE: Make sure the new fuel injection pump belt is correctly seated on
to the fuel injection pump drive pulleys.

Install a new fuel injection pump belt.

35. CAUTION: Make sure the fuel injection pump belt tensioner tang
is correctly located to the fuel injection pump cover backplate. Failure to
follow this instruction may result in damage to the components.

Install the new fuel injection pump belt tensioner.

Locate the tang on the new fuel injection pump belt tensioner into
the fuel injection pump cover backplate.
36. NOTE: Do not remove the fuel injection pump belt tensioner locking
pin before installing the new tensioner.

Install the new fuel injection pump belt tensioner retaining bolt.

Tighten to 25 Nm.

37. Remove and discard the fuel injection pump belt tensioner locking pin.

38. Install the fuel injection pump belt cover.

39. Install the engine compartment access panel retaining strip.


40. Install the engine harness retaining bolts.

41. Install the engine compartment access panel.

Left-hand drive vehicles


42. Install the wiper mounting arm and pivot shaft.
For additional information, refer to: Wiper Mounting Arm and Pivot Shaft
(501-16 Wipers and W ashers, Removal and Installation).

Right-hand drive vehicles


43. Install the engine compartment panel.

44. Install the cabin air filter housing.

You might also like