The document provides information about the Salwico IR Flame Detector Tester. The tester uses infrared light to test the functionality of Salwico flame detectors. It has an extension rod to reach detectors in different locations. The tester runs on 4 AA batteries and contains an infrared light source. It is compatible with several Salwico detector models and can test detectors from up to 5 cm away in continuous test mode.
The document provides information about the Salwico IR Flame Detector Tester. The tester uses infrared light to test the functionality of Salwico flame detectors. It has an extension rod to reach detectors in different locations. The tester runs on 4 AA batteries and contains an infrared light source. It is compatible with several Salwico detector models and can test detectors from up to 5 cm away in continuous test mode.
The document provides information about the Salwico IR Flame Detector Tester. The tester uses infrared light to test the functionality of Salwico flame detectors. It has an extension rod to reach detectors in different locations. The tester runs on 4 AA batteries and contains an infrared light source. It is compatible with several Salwico detector models and can test detectors from up to 5 cm away in continuous test mode.
The Salwico IR test lamp is used to perform There are two ways to test the detector: function test on Salwico IR flame detectors. (a) Press the Salwico IR test lamp against the The included extension rod makes it easy to test detector until the trigger switch initiate test detectors in different locations. procedure with an intermittent buzzer sound. After about 15-30 seconds, check if the detector has reacted to the test. Data (b) Activate "continuous test mode" by setting the Nominal voltage 6 VDC switch on top of the test lamp to "ON". This Battery type Alkaline LR6/AA x 4 mode will initiate buzzer sound. Light source Pliken bulb 4.8V 0.5A Hold the Salwico IR test lamp close to the detector so the distance between the test lamp Material: and the detector is within 5 cm. If the detector - Tester Polycarbonate reacts within 30 seconds under this condition, the - Extension rod Aluminium detector is functional. Colour Black If there is no response after 30 seconds in any of Weight 1070 g (incl. carrying-box) those tests there may be a problem with the Dimension tester W122 x H165 x D80 mm detector (or the Salwico IR test lamp itself). Refer Dimension box W225 x H197 x D169 mm to troubleshooting in the corresponding manual. Length ext. rod 1.4 - 4.0 m Special Note CAUTION! Compatibility Do not touch the surface of the infrared The Salwico IR test lamp is compatible to the following filter with your fingers. detectors: If the surface needs to be cleaned, use a cotton 5200236-00A Salwico AC-IR-3Fq swab with alcohol. Wipe gently. Be carefull not to 5200039-00A Salwico EVC-IR scratch the glass. N1122 Salwico NS-DIR
The specifications described herein are subject to change without notice. Data sheet no. 5100553-00A_Salwico IR Test lamp_M_EN_2014_B