Professional Documents
Culture Documents
Ques 1 PDF
Ques 1 PDF
(a) 3.5 Ω
(b) 16.4 Ω
(c) 3.69 Ω
(d) 45.15 Ω
Figure 3
(a) 0V
(b) 4V
(c) 2V
(d) 1V
4. Four cells, each of emf 1.5v and internal resistance 0.5 Ω are connected in parallel across an external resistance of
2.5Ω. What is the current supplied by each cell?
(a) 0.1427
(b) 2
(c) 0.515
(d) 0.634
6. One sine wave has a positive peak at 750 , another has a positive peak at 1000 . How much in each sine wave shifted
in phase from 00 reference.
(a) 4.02 A
(b) 4.2 A
(c) 2.97 A
(d) 0.42 A
8. For series RC circuit, the relation between voltage and current is
(a) voltage leads the current by φ
(b) voltage lags the current by φ
(c) voltage leads by φ
(d) voltage is equal to currents
9. In the circuit 9 shown, Power consumed by 2Ω resistor is
Figure 9
(a) 0.325 W
(b) 1.512W
(c) 3.750
(d) 0.0375
11. The armature of a 8-pole d.c generator has 960 conductors and runs at 400rpm. The flux per pole is 40m Wb.
Calculate the induced emf if the armature is lap wound?
(a) 250V
(b) 256V
(c) 300V
(d) 200V
12. A 4 pole shunt generator with lap-connected armature supplies a load of 200 A at 100 V. Shunt field resistance is
50 ohms, and armature resistance is 0.05 ohm. Calculate the total armature current
(a) 20 A
(b) 202 A
(c) 2020 A
(d) 200 A
14. A 230V dc shunt motor has an armature resistance of 0.3 Ω. Calculate the resistance to be connected in series with
the armature to limit the armature current to 75 A at starting
(a) 0 Ω
(b) 3.0667 Ω
(c) 2.7667 Ω
(d) 2 Ω
15. A 1000/200V transformer takes 0.3 A at p.f of 0.2 on open circuit. Find the magnetizing, and iron loss component
of no-load primary current
16. The frequency of voltage generated by an alternator having 4 poles and rotating at 1800rpm is hertz.
(a) 40
(b) 20
(c) 60
(d) 80
17. A 3-phase, 4-pole, 50Hz. Induction motor runs at 1440rpm determine the percentage slip of the induction motor.
(a) 8%
(b) 5%
(c) 2%
(d) 4%
18. The moving coil of a meter has 50 turns and width of 2cm and depth of 3m. it is placed in a uniform radial field of
5o, wb/m2 . Find the turning moment of coil when it is carrying, 1mA current.
(a) 1.5× 103 Nm
(b) 1.5× 102 Nm
(c) 1.5× 10− 6 Nm
(d) 1.5Nm
19. An ammeter is used to measure the flow of in a circuit
(a) Voltage
(b) Current
(c) Power
(d) Energy
20. Slow, but continuous rotation of the disc of an energy meter is called
(a) creeping
(b) sweeping
(c) crawling
(d) friction error