Professional Documents
Culture Documents
2018
Version 6.2
Page 1 of 8
Signal word Warning
Hazard statement(s)
H317 May cause an allergic skin reaction.
H411 Toxic to aquatic life with long lasting effects.
Precautionary statement(s)
P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.
P273 Avoid release to the environment.
P280 Wear protective gloves.
P333 + P313 If skin irritation or rash occurs: Get medical advice/ attention.
P362 + P364 Take off contaminated clothing and wash it before reuse.
P391 Collect spillage.
Supplemental Hazard none
Statements
2.3 Other hazards
This substance/mixture contains no components considered to be either persistent,
bioaccumulative and toxic (PBT), or very persistent and very bioaccumulative (vPvB)
at levels of 0.1% or higher.
Page 2 of 8
If swallowed
Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult
a physician.
4.2 Most important symptoms and effects, both acute and delayed
The most important known symptoms and effects are described in the labelling (see
section 2.2) and/or in section 11
4.3 Indication of any immediate medical attention and special treatment needed
No data available
Page 3 of 8
7.3 Specific end use(s)
Apart from the uses mentioned in section 1.2 no other specific uses are stipulated
Page 4 of 8
e) Melting Melting point/range: < 0 °C
point/freezing point
f) Initial boiling point 287 - 290 °C - lit.
and boiling range
g) Flash point 146 °C
h) Evaporation rate No data available
i) Flammability (solid, No data available
gas)
j) Upper/lower No data available
flammability or
explosive limits
k) Vapour pressure 0,1 hPa at 50 °C
l) Vapour density No data available
m) Relative density 0,97 g/cm3 at 25 °C
n) Water solubility ca.8,6 g/l
o) Partition coefficient: log Pow: 4,7
n-octanol/water
p) Auto-ignition 231 °C
temperature
q) Decomposition No data available
temperature
r) Viscosity No data available
s) Explosive properties No data available
t) Oxidizing properties No data available
9.2 Other safety information
No data available
Page 5 of 8
SECTION 11: Toxicological information
11.1 Information on toxicological effects
Acute toxicity
LD50 Oral - Rat - 3.730 mg/kg
Remarks: Sense Organs and Special Senses (Nose, Eye, Ear, and
Taste):Olfaction:Other changes. Sense Organs and Special Senses (Nose, Eye, Ear, and
Taste):Eye:Other. Behavioral:Somnolence (general depressed activity).
Inhalation: No data available
LD50 Dermal - Rabbit - > 2.000 mg/kg
Skin corrosion/irritation
Skin - Human
Result: No skin irritation
Serious eye damage/eye irritation
No data available
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Result: Not mutagenic in Ames Test
Carcinogenicity
No data available
IARC: No component of this product present at levels greater than or equal to 0.1% is
identified as probable, possible or confirmed human carcinogen by IARC.
Reproductive toxicity
No data available
Specific target organ toxicity - single exposure
No data available
Specific target organ toxicity - repeated exposure
No data available
Aspiration hazard
No data available
Additional Information
RTECS: GD6825000
To the best of our knowledge, the chemical, physical, and toxicological properties have
not been thoroughly investigated.
Page 6 of 8
invertebrates
Toxicity to algae EC50 - Algae - 1,89 mg/l - 72 h
12.2 Persistence and degradability
Biodegradability Result: - Readily biodegradable.
(OECD Test Guideline 301B)
12.3 Bioaccumulative potential
No data available
12.4 Mobility in soil
No data available
12.5 Results of PBT and vPvB assessment
This substance/mixture contains no components considered to be either persistent,
bioaccumulative and toxic (PBT), or very persistent and very bioaccumulative (vPvB)
at levels of 0.1% or higher.
12.6 Other adverse effects
Toxic to aquatic life with long lasting effects.
Further information
Page 7 of 8
EHS-Mark required (ADR 2.2.9.1.10, IMDG code 2.10.3) for single packagings and
combination packagings containing inner packagings with Dangerous Goods > 5L for
liquids or > 5kg for solids.
Page 8 of 8