Professional Documents
Culture Documents
5-1
Steps/Procedure:
Procedure in removing the contact breaker point
1. Prepare the tools and materials needed in removing the contact
breaker point.
Tools and materials needed:
Hand tools and Power tools,
Voltmeter
Timing light
Distributor test bench
Distributor assembly
Ignition coil and condenser
Actual vehicle equipped with conventional ignition System
2. Rerelease each screw in turn and then lift the cap.
3. Disconnect the wiring at the contact-breaker terminal post.
4. Connections may be a press-on fit or held by nuts.
5. Undo the screw or screws holding the assembly and lift it off.
6. Remove the nut from the threaded top of the terminal post, and
take off the connections.
7. The contact faces of the new points may be covered by a
protective coating.
8. Wash it off with petrol or paraffin, and dry.
Assessment Method: