Professional Documents
Culture Documents
Lab 1-Introduction To Catelog Window
Lab 1-Introduction To Catelog Window
Name:______________________________________________________
No ID: ____________
Objective: students will study the use of Catalog Window within ArcMap. In addition, students will
use the ArcToolbox geoprocessing tool to perform buffering zone analysis.
OBJEKTIVES
INSTRUCTIONS
1
Red line refer to what type of legend ____ _________
17. At Width section: type 1.50. Repeat the same step for Width 2.00, 2.50 and 3.00 any changes
to the Width _________
18. Click OK.
19. At Catalog Window, Click Toolboxes > System Toolboxes. You will see few toolbox were
listed.
20. Click to the toolbox Analysis Tools > Proximity and ‘double-click’ tool Buffer.
21. Dialog Buffer will be shown. In Input Features section, select Transmission.
22. At the Output Feature Class section, Name your data zone as Zon_100m and save under
folder geodatabase TNB.
23. In Linear unit section, type 100 and before that you have to make sure that the unit is in
Meters.
24. At Dissolve Type section, select ALL.
25. Click OK.
26. You will find that data polygon zone will be generated in the map display.
27. By repeating step 22-25, change your data zon to Zon_200m and Zon_300m, then save
under geodatabase TNB. What happen to the data polygon zon?
_______________________________________________________________________________
__________________________________________________________________________________
__________________________________________________________________________________
_____________________________________________________________________________
CONCLUSION:
_______________________________________________________________________________
__________________________________________________________________________________
__________________________________________________________________________________
_____________________________________________________________________________
Question:-