Professional Documents
Culture Documents
Access Platforms Stairs and Ladders User Guide-27 PDF
Access Platforms Stairs and Ladders User Guide-27 PDF
Selecting the Plane toggle changes the options displayed to the user for selecting the Lower
Working Point. The user can now specify a plane and direction onto which the Upper Work
Point will be projected.
The selected position value is used to position either the landing or the landing stringer
TOS, based on the selection made in FFL/TOS. Landing is either Flushed or placed above
the Landing Stringer based on the selection made in Flush with Landing / Above Landing.
The same applies for the Upper Work Point as well. Both these landings and the
intermediate landings if any will be of thickness provided in the Landing thickness.
The U-Flight Offset is the distance till which the U-Type Stair Flight extends along the
Normal direction between the picked points. If the user does not click Pick position for the
distance or enters a value then the Offset value is derived using optimum values.
4:3 12.0