Professional Documents
Culture Documents
555
(/fa/index.php/)
(/fa/../en(//)http://delaranrooz.com/new/fa)
CHEMICAL DESCRIPTION:
HAZARDOUS INGREDIENTS:
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 1/7
7/12/2020 (sea care o.s.d (c.555
3. HAZARDS IDENTIFICATION
INHALATION:
May cause imitation of mucous membranes. May cause headache and dizziness. Components of the
SKIN CONTACT:
EYE CONTACT:
INGESTION:
Harmful: may cause lung damage if swallowed. There may be irritation to the gastro - intestinal tract with nausea
and vomiting. Can cause chemical pneumonia if aspirated into lungs following ingestion.
ENVIRONMENTAL HAZARDS:
None known.
4. FIRST-AID MEASURE
INHALATION:
EYE CONTACT:
immediately gently irrigate with clean water for at least 15 minutes. move eyeball and keep eyelids wide open and
INGESTION:
Do not induce vomiting: Contains petroleum distillates and/or aromatic solvents. If conscious
washout mouth and give one pint of water to drink. Obtain medical attention.
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 2/7
7/12/2020 (sea care o.s.d (c.555
ADDITIONAL INFORMATION:
If unconscious do not give anything by mouth, place in the recovery position, check breathing and pulse. If necessary
5. FIRE-FIGHTING MEASURES
EXTINGUISHING MEDIA:
In case of fire, wear a full face positive - pressure self contained breathing apparatus and protective suit. Water
PERSONAL PRECAUTIONS :
Remove sources of ignition. Ensure adequate ventilation. Wear organic vapours respirator if ventilation is
inadequate. Wear chemical resistant apron, chemical splash goggles, impervious gloves and Wellington boots.
Contain and absorb with sand or vermiculite and mix well. Collect up and remove to a safe place
until disposal. Wash site of spillage thoroughly with water and detergent. Assistance can obtained
HANDLING:
Avoid contact with skin and eyes. If clothing is contaminated, remove clothing and thoroughly wash
the affected area. Launder contaminated clothing before reuse. Ensure adequate ventilation, No
STORAGE CONDITIONS:
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 3/7
7/12/2020 (sea care o.s.d (c.555
Keep container tightly closed in a cool, well- ventilated place. Connections must be grounded to avoid electrical
charges. Store away from heat and sources of ignition. store separately from oxidizers. Storage for more than two
NATIONAL REGULATIONS UK
ENGINEERING MEASURES:
Local exhaust ventilation if necessary to control airborne levels below the exposure
guidelines.
RESPIRATORY PROTECTION:
An approved respirator must be worn if the occupational exposure limit is likely to be exceeded.
HAND PROTECTION:
SKIN PROTECTION:
Not normally needed. Wear impervious apron (if skin contact is likely).
EYE PROTECTION:
HYGIENE RECOMMENDATIONS:
NOTE: These physical properties are typical values for this product.
FORM: Liquid
COLOUR: Yellow
ODOUR: Hydrocarbon
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 4/7
7/12/2020 (sea care o.s.d (c.555
MELTING POINT: NA
PH: NE
OCTANOL/WATER COEFICIENT: NE
VISCOSITY NA
BULK DENSITY NE
FREEZING POINT: NE
POUR POINT: NE
STABILITY:
CONDITION TO AVOID:
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 5/7
7/12/2020 (sea care o.s.d (c.555
No data available.
No data available.
SENSITIZATION:
No data available.
No data available.
No data available.
No data available.
ECOTOXICOLOGICAL EFFECTS:
No data available.
13. DISPOSALCONSIDERATION
1991.
EC CLASSIFICATION:
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 6/7
7/12/2020 (sea care o.s.d (c.555
Xn, HARMFUL
RISK PHRASES:
SAFETY PHRASES:
S26 In case of contact with eyes, fines immediately with plenty of water and seek medical advice.
fa/index.php/m-s-d-s/325-sea-clean-c-/) ﻗﺒﻠﯽ
(535
fa/index.php/m-s-d-s/323-s-a-/) ﺑﻌﺪی
(100
ﺗﻤﺎس ﺑﺎ ﻣﺎ
info@delaranrooz.com
www.delaranrooz.com/fa/index.php/m-s-d-s/324-sea-care-o-s-d-c-555 7/7