Professional Documents
Culture Documents
ISO14692 Modelling in Caesar II 5
ISO14692 Modelling in Caesar II 5
10 (& below)
Since there are growing number of current projects are required to follow ISO14692 in GRE
piping analysis, we are still "stuck" with Caesar II 5.10 (&below). Actual release date for C2
V5.20 are still unknown at the moment.
The are ways to "simulate" ISO14692, recommended by Mr Richard Ay (COADE, Inc.) using
C2 v5.10 (&below). First, we need to know the major difference between these 2 codes:
1. SIFS are different for bends for piping diameters below 20”. ISO14692 had limit the SIF for
Bend and Tee at 2.5 and 2.3 respectively.
2. Failure envelopes for ISO-14692 can be slightly more detailed (and therefore less
conservative) often being defined by one more data point (having pentagon shape rather than
trapezoid shape).
3. Allowable stress levels may be increased for Operating and Occasional load cases, by 24%
and 33% respectively, as compared to Sustained load cases.
4. The “f2” term is excluded from the bending stress in ISO-14692, as opposed to being included
in UKOOA. This resulting a slightly increase of Bending Stress in ISO14692.
**p.s. From my experience, in step 6, I'll construct 3 types of Failure envelops, based on the size
of 124% for operating and 133% for occasional stresses for easy comparison.
There are one more doubt for using ISO14692, is the "pressure stress multiplier, m" for the tee &
elbow. The related explanation in ISO14692-3, Annex D.2.2.4 for elbow and D2.3.4 for tee.
Both paragraph saying that if the fittings have been qualified according to precedure given in
ISO14692-2, the pressure stress multiplier value may set as 1.
Else, there are some default value for bend, and formula to get the mutiplier value.