Professional Documents
Culture Documents
RFG-1A
Radiofrequency Generator
Impedance Monitor
Electrode impedance is measured
continuously at all times, including
stimulation and lesioning. This enables
detection of any changes during the
critical procedure steps. Its wide range
accomodates even the smallest electrodes
and future developments. Impedance is
shown on a large green LED display for
instant clarity. Temperature Monitor
Electrode temperature, the most critical RF
Reference Connection heating parameter, is shown on a large red
The reference jack connects to the Cosman digital display that can be seen from across the
Disposable Grounding Pad or to the Non room.
Disposable Ground Plate.
Output Control
In STIM, Pulsed RF, or RF modes, the
Active Electrode Connection OUTPUT CONTROL knob raises the output
The active jack connects the outputs to the smoothly, even at the very low levels. A yellow
Stimulation Mode Selector Pulsed RF Mode Selector Automatic Temperature Control pilot light and an audible beeper signify
active electrode. Continuous RF Mode Selector
delivery of output. The output can be shut off
This pushbutton selects the Stimulation This pushbutton selects the Pulsed RF This pushbutton selects the continuous RF Either Manual or Automatic Temperature at any time.
section. section. section. Control can be selected. Preset set
temperatures can be selected and are
shown on the digital display.
RFG-1A Options
Graphic Display Outputs Carrying and Tilt Handle Storage and Travel Case
The RFG-GO Graphical Output Jacks enable The HAN Handle is a convenient carrying The SC-1 Storage Case provides secure
real-time graphic display and storage of handle (see previous page) and also protection for storage and transportation.
RFG-1A parameters of a procedure on a enables variable tilt angle for easy viewing in
laptop computer using the CB120 cable. the procedure room (see front cover).
Face Cover
The RFG-FC-1 attaches to the front face,
protecting it in transport or storage.
Technical Specifications
ELECTRICAL SUPPLY RF GENERATOR AUTOMATIC TEMPERATURE CONTROL
Domestic: 120 Vac Continuous RF Mode Select: ON or OFF
International: 100 Vac, 220 Vac, 240 Vac Continuous RF: 50, 55, 60, 65, 70, 75, 80,
Voltage: 0-70 Volts (rms)
85, 90 oC
GENERAL Current: 0-750 mA
Pulsed RF: 42 oC
Size: W 14” (35.5 cm), H 6” (15.3 cm), Power: 0-50 Watts
D 10.5” (26.7 cm) OUTPUT PORTS (Optional)
Pulsed RF Mode
Weight: 15 lbs (6.8 Kg) RF Volts: 0-100 Volts = 0-1 VDC
Voltage: 0-100 Volts (peak) RF Current: 0-750 mA = 0-.75 VDC
IMPEDANCE MONITOR
Pulsed Rate: 1, 2, 3, 4, 5, 6, 7, 8 Hz RF Watts: 0-50 watts = 0-.5 VDC
Range: 0-3000 ohms digital
Pulse Duration: 5, 10, 20, 30 mS Impedance: 0-3000 ohms = 0-1 VDC
Resolution: 1 ohm between 0-999,
TIMER Temperature: 0-100 oC = 0-1 VDC
10 ohms between 1000-3000
Selectable: 30, 60, 90, 120, 180, 600 Sec STANDARDS
STIMULATOR
TEMPERATURE MONITOR Unit meets CSA Canadian and USA
Pulse Rate: 2, 5, 50, 75, 100, 150, 180,
200 Hz Range: 0-100 oC standards.
Pulse Duration: 0.1, 0.5, 1, 2, 3 mS Resolution: 1 oC
0050
Voltage Stimulation Mode: 0-3 Volts Cosman Medical, Inc. is an ISO-13485
Constant Current Stimulation Mode: 0-10 mA certified company. Rx Only.
®
COSMA N 76 Cambridge Street, Burlington, Massachusetts 01803-4140 U.S.A.
Toll Free Tel: 888-8COSMAN (888-826-7626) Tel: 781-272-6561
www.cosmanmedical.com
Fax: 781-272-6563
m e d i ca l Inc .