This document discusses connecting Electrical InterMiCOM devices using EIA(RS)232 communication. EIA(RS)232 is suitable for short distance connections less than 15m, and for these direct connections the maximum baud rate can be used. For long distance connections over 15m, indirect connections should be made using modems, and the baud rate should be chosen to suit the communications network. The EIA(RS)232 connector is located on the bottom of the second rear communication board of the device.
This document discusses connecting Electrical InterMiCOM devices using EIA(RS)232 communication. EIA(RS)232 is suitable for short distance connections less than 15m, and for these direct connections the maximum baud rate can be used. For long distance connections over 15m, indirect connections should be made using modems, and the baud rate should be chosen to suit the communications network. The EIA(RS)232 connector is located on the bottom of the second rear communication board of the device.
This document discusses connecting Electrical InterMiCOM devices using EIA(RS)232 communication. EIA(RS)232 is suitable for short distance connections less than 15m, and for these direct connections the maximum baud rate can be used. For long distance connections over 15m, indirect connections should be made using modems, and the baud rate should be chosen to suit the communications network. The EIA(RS)232 connector is located on the bottom of the second rear communication board of the device.
Electrical InterMiCOM uses EIA(RS)232 communication presented on a 9-pin ‘D’ type connector. The connector is labelled SK5 and is located at the bottom of the 2nd Rear communication board. The port is configured as standard DTE (Data Terminating Equipment).
6.1 SHORT DISTANCE
EIA(RS)232 is suitable for short distance connections only - less than 15m. Where this limitation is not a problem, direct connection between devices is possible. For this case, inter-device connections should be made as shown below the figure below.
IED IED
E02522
Figure 160: Direct connection
For direct connection, the maximum baud rate can generally be used.
6.2 LONG DISTANCE
EIA(RS)232 is suitable for short distance connections only - less than 15m. Where this limitation is a problem, direct connection between devices is not possible. For this case, inter-device connections should be made as shown below the figure below.
IED Modem Modem IED
E02523
Figure 161: Indirect connection using modems
This type of connection should be used when connecting to devices that have the ability to control the DCD line. The baud rate should be chosen to be suitable for the communications network. If the Modem does not support the DCD function, the DCD terminal on the IED should be connected to the DTR terminal.