Professional Documents
Culture Documents
Quick Start - High Power WiFiX - 1QSHPWX100
Quick Start - High Power WiFiX - 1QSHPWX100
Upon connecting T1 to the ICU - wireless connection between the ICU and the
panel is not possible.
1
Code: 1QSHPWX100
High Power WiFiX Quick Start
This sheet is not intended to replace a thorough reading of the manual
-sight), Xbit’s Status Bar will indicate Imager Online in the lower-right corner and the Link will display 100 Mbps.
The High Power WiFiX will not operate if the Imager is not online. If
the Imager Online indication does not appear, perform Search Imager.
See the manual for instructions.
3. When you are ready to grab the image, enter Alt-F1. (To abort, click Cancel).
Warning:
• Do NOT connect or disconnect the ICU/Imager Connecting Cable
while the ICU is ON and the ICU and Imager power LEDs are lit.
• Before disconnecting the cable, make sure the Imager is offline.
• Quit Xbit before disconnecting the cable. Verify that the Power light
on the ICU is off and then disconnect the cable.
2. You may re-charge the transceivers by using the data cables. Plug one end into the transceiver as described above
and the other end into the interface box connected to an external power source.
2
Code: 1QSHPWX100