Professional Documents
Culture Documents
TYPICAL APPLICATIONS
MIXING
MasterMatrix 110 is optimized for use
MasterMatrix 110 is compatible with all types of
whenever an increase in mix viscosity would be
cements. The rheological behaviour induced by
advantageous, especially for:
MasterMatrix 110 is optimised when used in
SCC (Self-compacting concrete) with a low combination with MasterGlenium
Fines content (material passing the 0.125 superplasticizer. It is incompatible for use with
mm sieve) naphthalene sulphonate based superplasticizers.
PACKAGING
MasterMatrix 110 is supplied in 210 L drums,
1,000 L containers or in bulk.
MasterMatrix® 110
STORAGE AND SHELF LIFE Spillage
MasterMatrix 110 must be stored at Chemical products can cause damage; clean
temperatures above 5°C. Store under cover, spillage immediately.
out of direct sunlight and protect from extreme
temperatures. Failure to comply with the QUALITY AND CARE
recommended storage conditions may result in All products originating from BASF’s Dubai, UAE
premature deterioration of the product or facility are manufactured under a management
packaging. For special storage advice consult system independently certified to conform to the
our Technical Services Department. requirements of the quality, environmental and
Shelf life is 12 months if stored according to occupational health & safety standards ISO 9001,
manufacturer’s instructions in original ISO 14001 and ISO 45001.
unopened packaging.
* Properties listed are based on laboratory controlled tests.
BASF_CC-UAE/M_Matrix_110_04_08/v1/12_13/v2/05_19
The technical information and application advice given in this BASF publication are based on the present state of
STATEMENT OF our best scientific and practical knowledge. As the information herein is of a general nature, no assumption can be
RESPONSIBILITY made as to a product's suitability for a particular use or application and no warranty as to its accuracy, reliability or
completeness either expressed or implied is given other than those required by law. The user is responsible for
checking the suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF either
NOTE orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since they, and not
BASF, are responsible for carrying out procedures appropriate to a specific application.