Professional Documents
Culture Documents
Therefor the following description might be quite usefull to those, who intend to perform the experiments described in the book and don�t want
start up from the scratch and collect the sircuitplans, join them together and make that prototypeboard to create the connection between the
breadboardsystem and the Apple II. This board contains the chips and the layout how to monitor the the interface and the coded logic on the
breadboard and therby verify the own design by experiments.
Targeting to save resources the Interface for the Apple II and the prototyping card are linked together as one large board and after making that boar
the user may saw the interfacecard apart and link both boards with a flatribbon cable. this permits the interface card to stay inside of the Apple II ,
while the prototyping board and the breadboardsystem remain outside apart of the Apple II.
Here is the general view of the prototyping card and the interfacecard after they have been sawed apart and connected together with a
flatribbon cable. Please note that the prototyping card has a section on board that is designed to supply the card and the breadboardsystem
with independant stabilized power from external transformator with 24 Volt and 12 Volt ( both brancehes each 1 Ampere ). The only requirement
is that the GND od the Apple II and the external systems are linked together to ensure that the systems interact with the correct voltage levels.
This is assured by the connection of the interfacecards. In case that the external powersupply is used the wires connecting the power from the
Apple to the prototypingboard should be not soldered in place.
Please also pay attention to the red side of the ribboncable indicating the side of pin 1 !
here is the view to the solderside of the card:
Here is the view to the traces at the componentside:
And here is the view to both layers combined together:
and here is the view to the layout of the components:
Please note that several chips have been placed inside of larger ICsockets. The purpose is the each pin of the chip has connection to 2
pins of the larger socket and therefor there are for each pin of the chip 2 pins availiable for access at the surrounding socket for use with
the breadboardsystem.
Those chips which are proposed for use only by one connection the related socket to grant access to the pins is located besides of the
chip and grants only one pin access to the related gate.
This is explained by the colored fields of the following picture:
For use of this board it�s highly recommended to download the related book by using the link in the title of this page
and read the book before starting up with the experiments. Otherwise you might damage your computer !
The basics explained in the book are essential for understanding the experiments and preventing the system
from harming the computer !
and of course here a view to the circuitplan:
Alternatively i also publish here the "older" version i made about 25 years ago.... in those days i etched my own single sided PCB�s
at home with a "home brew" etching system by lighting the PCB�s with ultraviolett lightbulb and afterwards etching in a cavern made
of acryl and heated with a heater usually used in aquariums and transferring air bubbles in the cavern / tank with a pump used for
adding air in the water of an aquarium.
The film for the single sided PCB :
The population of the PCB looked like this :
due to european laws and german court decision:
I hereby declare no responsibility to any "deep links" resulting from the links in this page. I have no influence to the pages linked hereby in this page and the
contents in those pages. I therefor can�t take any kind of responsibility to contents in the pages, where these links direct the readers browser to nor to the
contents resulting from following up links from those pages. The reference to contents by this links is dependent ro the status of the date when the links have
been set ( April 2013 ) and it might occur that references and contents may change by the fact that domains may have been discontinued from their former owners.
In such cases i can�t take any kind of responsibility to the changed contents. this is specialy valid to banners, advertisements or merchandising links in the targeted
pages.