You are on page 1of 21

Geotech & St

Flat:-16B- Rupayan
80 VIP Road, Kakrai
Input Cell

INPUT
Location Bagerhat
Basic Wind Speed, V 77.50 m/s 173.4 mph
Exposure Category C
Building Height, h (Above GL) 30.50 m
Wind is Width perpendicular to the wind direction, B 18.00 m
perpendicular to B Width Pararell to the wind direction, L 12.00 m
Framing Type CMRF Natural Frequency will vary f
Damping Ratio 0.020 1% ~2% for steel and concre
Gust Effect Factor 1.006
Frequency determination
Importance facotor,I 1.00
method (BNBC/ASCE)
Velocity Pressure,qz 3.130 Kz (kN/m2) case 1: All components, clad
Case 2 case 2: High rise building

Cumulative Height, above


Level individual storey ht (m) kz (A)
GL (m)

0 (EGL to PL) 0.50 0.5 -


1 3.00 3.5 -
2 3.00 6.5 -
3 3.00 9.5 -
4 3.00 12.5 -
5 3.00 15.5 -
6 3.00 18.5 -
7 3.00 21.5 -
8 3.00 24.5 -
9 3.00 27.5 -
10 3.00 30.5 -
Geotech & Structures
Flat:-16B- Rupayan Karim Tower Contact Informations
80 VIP Road, Kakrail, Dhaka-1000 Cell: +88 01885 973767
Email: design@geostruc.com

Terms and Conditi

perpendicular to B
01. This excel is property of Geotech & S
regarding this excel program is reserved
Wall pressure Coefficient
Surface L/B Cp
All 0.8
02. This excel program is only for learnin
Windward Wall professional use it must be varified with
Side Wall All -0.7
Lee ward wall 0.67 -0.50
03. It will be highly apprecialbe If you in
inconsistancy of this excel program
ural Frequency will vary for different MRFs'. CMRF=Concrete MRF, SMRF= Steel MRF.
~2% for steel and concrete buildings are typically used in USA. However, ISO suggests 1%~1.5% for steel and concrete buildings.

Frequency determination
BNBC
method (BNBC/ASCE)
e 1: All components, cladding, low rise building.
e 2: High rise building Wind Perpendicular to B
Total
pz(kN/m2), pz(kN/m2),
kz (B) kz (C) qz(kN/m2) ph(kN/m2) Pressure
windward leeward
(kN/m2)

- 1.03 3.22 2.59 1.62 2.26 4.85


- 1.03 3.22 2.59 1.62 4.85
- 1.10 3.43 2.76 1.72 5.01
- 1.17 3.66 2.95 1.84 5.20
- 1.23 3.84 3.09 1.93 5.34
- 1.27 3.99 3.21 2.00 5.46
- 1.31 4.11 3.31 2.07 5.56
- 1.35 4.22 3.40 2.12 5.65
- 1.38 4.32 3.47 2.17 5.73
- 1.41 4.40 3.54 2.21 5.80
- 1.43 4.48 3.61 2.26 5.86
Dual system
mations structural steel and concrete buildings with
85 973767 other lateral-force-resisting systems
n@geostruc.com
CMRF
Concrete moment resisting frame
Terms and Conditions
SMRF
is property of Geotech & Structures. Any rights Steel moment resisting frame
s excel program is reserved to GnS

program is only for learning purpose. So, for


use it must be varified with manual calculations

highly apprecialbe If you inform GnS any


of this excel program

ncrete buildings.

ind Perpendicular to B

Storey force, Storey force,


Area(m2)
(kN) (kip)

36 175 39.2
54 262 58.8
54 271 60.8
54 281 63.1
54 289 64.8
54 295 66.3
54 300 67.5
54 305 68.6
54 309 69.5
54 313 70.4
27 158 35.6
Gust Effect Factor , G (Rigid Structures):
For rigid structures (fundamental frequency is greater than or equal to 1 Hz) as defined in Sec 2.1.3, the gust-effect fa
Gust Effect Factor , Gf (Flexible or Dynamically Sensitive Structures):
For flexible or dynamically sensitive structures as defined in Sec 2.1.3 (fundamental natural frequency less than 1 Hz),

Calculations for Gf
Natural Frequency, n1 0.99 Hz
Peak Factor for Background Response, g Q 3.40
Peak Factor for Wind Response, g v 3.40
Peak Factor for Resonant Reaponse, g R 4.187
Mean Hourly Wind Speed, Vz 66.31 m/s
Mean Hourly Wind Speed Power Law Exponent, ā 0.11
Mean Hourly Wind Speed Factor, b 0.80
Turbulence Intensity Factor, c 0.15
Integral Length Scale Factor, ℓ 198.12
Integral Length Scale Power Law Exponent, ε 0.125
Exposure Constant, zmin 2.13 m
Equivalent Height of Structure, z 18.30 m
Reduced Frequency, N1 3.191
Rn Value 0.067
η for Rh 2.095
η for RB 1.237
η for RL 2.760
Rh Value 0.365
RB Value 0.509
RL Value 0.297
Resonant Response Factor, R 0.647
Integral Length Scale of Turbulence, L z 213.67 m
Background Response Factor, Q 0.895
Intensity of Turbulance, Iz 0.136
Gust Effect Factor, Gf 1.006

Table 1
Exposure ā b c ℓ
A 0.25 0.45 0.30 97.54
B 0.15 0.65 0.20 152.40
C 0.11 0.80 0.15 198.12

Table 2
Framing Type h Frequency (ASCE) Approximate (BNBC)
CMRF 30.50 m 0.69 Hz 0.99
SMRF 30.50 m 0.56 Hz 0.90
Dual Sys. 30.50 m 0.75 Hz 1.05
Town V(m/s)
Angarpota 47.8
Bagerhat 77.5 ASCE
Bandarban 62.5 BNBC
Barguna 80
Barisal 78.7
Bhola 69.5
Bogra 61.9
Brahmanbaria 56.7
Chandpur 50.6
Chapai Nawabganj 41.4
Chittagong 80
Chuadanga 61.9
Comilla 61.4
Cox’s Bazar 80
Dahagram 47.8
Dhaka 65.7
Dinajpur 41.4
Faridpur 63.1
Feni 64.1
Gaibandha 65.6
Gazipur 66.5
Gopalganj 74.5
Habiganj 54.2
Hatiya 80
Ishurdi 69.5
Joypurhat 56.7
Jamalpur 56.7
Jessore 64.1 Exposure α
Jhalakati 80 A 7
Jhenaidah 65 B 9.5
Khagrachhari 56.7 C 11.5
Khulna 73.3
Kutubdia 80 Selected 11.5
Kishoreganj 64.7
Kurigram 65.6
Kushtia 66.9
Lakshmipur 51.2
Lalmonirhat 63.7
Madaripur 68.1
Magura 65
Manikganj 58.2
Meherpur 58.2
Maheshkhali 80
Moulvibazar 53
Munshiganj 57.1
Mymensingh 67.4
Naogaon 55.2
Narail 68.6
Narayanganj 61.1
Narsinghdi 59.7
Natore 61.9
Netrokona 65.6
Nilphamari 44.7
Noakhali 57.1
Pabna 63.1
Panchagarh 41.4
Patuakhali 80
Pirojpur 80
Rajbari 59.1
Rajshahi 49.2
Rangamati 56.7
Rangpur 65.3
Satkhira 57.6
Shariatpur 61.9
Sherpur 62.5
Sirajganj 50.6
Srimangal 50.6
St. Martin’s Island 80
Sunamganj 61.1
Sylhet 61.1
Sandwip 80
Tangail 50.6
Teknaf 80
Thakurgaon 41.4
ed in Sec 2.1.3, the gust-effect factor shall be taken as 0.85.

natural frequency less than 1 Hz), the gust-effect factor shall be calculated by:

Gf Directionality Factor,kd 0.85


Table 2 Topographic Factor 1
gQ = 3.4 0.5 0 0
gv = 3.4 qz 0.00
gR = √[2 ln(3600n1)]+0.577/√[2 ln(3600n1)] 0.5 0 0
Vz = b*((z/10)^ā)*V

Exposure Type Framing System


A CMRF
Table: 1
B SMRF
C Dual Sys.

z = 0.6h ≥ zmin
N1 = n1Lz/Vz
Rn = 7.47N1/(1+10.3N1)5/3
η = 4.6n1h/Vz
η = 4.6n1B/Vz
η = 15.4n1L/Vz
Rh = (1/ηH)-1/(2ηH2)(1-e-2ηH) for ηH> 0
RB =(1/ηB)-1/(2ηB2)(1-e-2ηB) for ηB> 0
Rl = (1/ηL)-1/(2ηL2)(1-e-2ηL) for ηL> 0
R = √[(1/β)RnRhRB(0.53+0.47RL)]
Lz = ℓ(z/10)ε
Q = √[1/(1+0.63((B+h)/Lz)0.63)] exposure A
Iz = c(10/z)1/6 1.00 2.00 selected
2 2 2 2
Gf = 0.925[(1+1.7Iz√[gQ Q +gR R ])/(1+1.7gvIz)] 0.70 1.03 1.03
0.70 1.03 1.03
1 0.70 1.10 1.10
ε zmin (m) 2 1.17 1.17 1.17
0.33 9.14 1.23 1.23 1.23
0.20 4.57 1.27 1.27 1.27
0.13 2.13 1.31 1.31 1.31
1.35 1.35 1.35
1.38 1.38 1.38
1.41 1.41 1.41
1.43 1.43 1.43
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
zg 0.70 1.03 1.03
365.76 0.70 1.03 1.03
274.32 0.70 1.03 1.03
213.36 0.70 1.03 1.03
0.70 1.03 1.03
213.36 0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
0.70 1.03 1.03
𝑞𝑧 = 0.000613𝐾𝑧 𝐾𝑧𝑡 𝐾𝑑 𝑉 2 𝐼 ; (kN/m2), V in m/s
0.00000 ഥ
Exposure 𝜶 𝒛𝒈 (m) ෝ
𝒂 ෡
𝒃 ഥ
𝛂 𝒃 c 𝒍 (m) 

A 7.0 365.76 1/7 0.84 1/4.0 0.45 0.30 97.54 1/3.0
0 B 9.5 274.32 1/9.5 1.00 1/6.5 0.65 0.20 152.4 1/5.0
C 11.5 213.36 1/11.5 1.07 1/9.0 0.80 0.15 198.12 1/8.0
*𝑧𝑚𝑖𝑛 = Minimum height used to ensure that the equivalent height z is greater of 0.6h or 𝑧𝑚𝑖𝑛 .
raming System For buildings with h ≤𝑧𝑚𝑖𝑛 , 𝑧ҧshall be taken as 𝑧𝑚𝑖𝑛 .

Exposure (m)
A 7 365.76 7-Jan 0.84
B 9.5 274.32 1/9.5 1
C 11.5 213.36 1/11.5 1.07

exp B exp C h(m) case-I Case-II


1.03 1.03 0 0.7 0.57
1.03 1.03 4.6 0.7 0.57 0.85 1.03
1.10 1.10 6.1 0.7 0.62 0.9 1.08
1.17 1.17 7.6 0.7 0.66 0.94 1.12
1.23 1.23 9.1 0.7 0.7 0.98 1.16
1.27 1.27 12.2 0.76 0.76 1.04 1.22
1.31 1.31 15.2 0.81 0.81 1.09 1.27
1.35 1.35 18 0.85 0.85 1.13 1.31
1.38 1.38 21.3 0.89 0.89 1.17 1.34
1.41 1.41 24.4 0.93 0.93 1.21 1.38
1.43 1.43 27.41 0.96 0.96 1.24 1.4
1.03 1.03 30.5 0.99 0.99 1.26 1.43
1.03 1.03 36.6 1.04 1.04 1.31 1.48
1.03 1.03 42.7 1.09 1.09 1.36 1.52
1.03 1.03 48.8 1.13 1.13 1.39 1.55
1.03 1.03 54.9 1.17 1.17 1.43 1.58
1.03 1.03 61 1.2 1.2 1.46 1.61
1.03 1.03 76.2 1.28 1.28 1.53 1.68
1.03 1.03 91.4 1.35 1.35 1.59 1.73
1.03 1.03 106.7 1.41 1.41 1.64 1.78
1.03 1.03 121.9 1.47 1.47 1.69 1.82
1.03 1.03 137.2 1.52 1.52 1.73 1.86
1.03 1.03 152.4 1.56 1.56 1.77 1.89
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03
1.03 1.03

𝒃 c 𝒍 (m) 
ഥ 𝒛𝒎𝒊𝒏 (m)*
.45 0.30 97.54 1/3.0 9.14
.65 0.20 152.4 1/5.0 4.57
.80 0.15 198.12 1/8.0 2.13
z is greater of 0.6h or 𝑧𝑚𝑖𝑛 .

c lIm) (m)*
1/4.0 0.45 0.3 97.54 1/3.0 9.14
1/6.5 0.65 0.2 152.4 1/5.0 4.57
1/9.0 0.8 0.15 198.12 1/8.0 2.13

You might also like