Professional Documents
Culture Documents
Splice program
Heater program
Ver1.02
* Setup and change the Heater program in the same pro-
1 Splice program setting cedures as described below. Evaluating splice quality
Re-do splicing.
1. Move the cursor “ ” using 2. Select fiber profile category 3. Move the cursor “ ” to the
▼▲ keys, select splice pro- and press key. splice program you would like
to use and press key. Evaluating fiber protection sleeve
gram and press key.
* Prepare the fiber again and repeat the arc test until “Good NG
2 Perform an arc test arc state.” is displayed. 1: The shrinking sleeve is not centered over the splice