Professional Documents
Culture Documents
1 Which of The Following Statements Are TRUE 1
1 Which of The Following Statements Are TRUE 1
a) When the enthalpy of air is equal to the enthalpy of saturated air at the wetted surface
temperature, then there is no sensible heat transfer between air and the wetted surface
b) When the enthalpy of air is equal to the enthalpy of saturated air at the wetted surface
temperature, then there is no latent heat transfer between air and the wetted surface
c) When the enthalpy of air is equal to the enthalpy of saturated air at the wetted surface
temperature, then there is no net heat transfer between air and the wetted surface
d) When the enthalpy of air is equal to the enthalpy of saturated air at the wetted surface
temperature, then the wet bulb temperature of air remains constant
Ans.: c) and d)
2. . Which of the following statements are TRUE?
a) In an air washer, water has to be externally cooled if the temperature at which it is
sprayed is equal to the dry bulb temperature of air
b) In an air washer, water has to be externally heated if the temperature at which it is
sprayed is equal to the dry bulb temperature of air
c) In an air washer, if water is simply recirculated, then the enthalpy of air remains nearly
constant at steady
d) In an air washer, if water is simply recirculated, then the moisture content of air
remains nearly constant at steady state
Ans.: b) and c)
3.An air stream at a flow rate of 1 kg/s and a DBT of 30 C mixes adiabatically with
another air stream flowing with a mass flow rate of 2 kg/s and at a DBT of 15o C.
Assuming no condensation to take place, the temperature of the mixture is
approximately equal to:
a) 20o C b) 22.5 o C c) 25o C d) Cannot be found
Ans.: a
4. Which of the following statements are TRUE?
a) As the by-pass factor (BPF) of the cooling coil increases, temperature difference
between air at the outlet of the coil and coil ADP decreases
b) The BPF of the coil increases as the velocity of air through the coil increases
d) Sensible heat factor is low for air conditioning plants operating in humid climates
Ans.: a) and d)
a) During sensible cooling of air, both dry bulb and wet bulb temperatures decrease
b) During sensible cooling of air, dry bulb temperature decreases but wet bulb
temperature remains constant
c) During sensible cooling of air, dry and wet bulb temperatures decrease but dew point
temperature remains constant
d) During sensible cooling of air, dry bulb, wet bulb and dew point temperatures decrease
Ans.: a) and c)
7. A mixture of dry air and water vapour, when the air has diffused the maximum
amount of water vapour into it.
d)none of these
Ans: b
9. For unsaturated air, the dew point temperature is ---- wet bulb temperature
a)Equal to
b)Less then
c)More than.
Ans: b
10.. The difference between dry bulb temperature and wet bulb temperature
Ans: b
11. The vertical and uniformly spaced lines on a psychrometric chart indicates
Ans: a
Ans:
d
Ans:
c
Ans:
b
15. During sensible cooling of air, the wet bulb temperature
Ans:
b
16. The process generally used in winter air conditioning to warm and humidify the
air
Ans: c
17. For summer air conditioning, the relative humidity should not be less than
Ans:
b
18. For winter air conditioning, the relative humidity should not be more than
Ans: a
19. The sensible that factor for auditorium or cinema hall is generally kept as
20. The conditioned air supplied to the room must have the capacity to take up
Ans: c
d)all
Ans: a
23. Air at 10˚C is heated to 15˚C using a heater with surface temperature of 20˚C.
the by-pass factor is
a)0.5
b)0.15
c)0.1
d)0.2 Ans: a
24. The by-pass factor of a cooling coil is 0.2. if the surface temperature is 5˚C and
the air enters at 40˚C, the air exit temperature is
a)5˚C
b)12˚C
c)20˚C
d)40˚C Ans: b
30. The cooling tower uses the phenomenon of evaporative cooling to cool warm
water above the dbt of air.
a) true
b) false
33. Which of the following is true?(here pa=partial pressure of dry air, pw=partial
pressure of water vapour, p=atmospheric pressure)
a) p=pw
b) p=pa
c) p=pw + pa
d) all of the mentioned
34. In a mixture of dry air and water vapour,
a) mole fraction of dry air = pa/p
b) mole fraction of water vapour = pw/p
c) both of the mentioned
d) none of the mentioned
36. When unsaturated air flows over a sheet of water in an insulated chamber
a) specific humidity of air decreases
b) the water evaporates
c) both air and water are cooled during evaporation
d) all of the mentioned
37. A room is filled with saturated moist air at 25°Cand a total pressure of 100 kPa.
If the mass of dry air in theroom is 100 kg, the mass of water vapor is
(a) 0.52 kg
(b) 1.97 kg
c) 2.96 kg
(d ) 2.04 kg
(e) 3.17 kg
38. A room contains 50 kg of dry air and 0.6 kg of water vapor at 25°C and 95 kPa
total pressure. The relative humidity of air in the room is
(a) 1.2%
b) 18.4%
(c) 56.7%
(d ) 65.2%
(e) 78.0%
39. A 40-m3 room contains air at 30°C and a total pressure of 90 kPa with a relative
humidity of 75 percent. The mass of dry air in the room is
(a) 24.7 kg
(b) 29.9 kg
(c) 39.9 kg
(d ) 41.4 kg
e) 52.3 kg
40. A room contains air at 30°C and a total pressure of 96.0 kPa with a relative
humidity of 75 percent. The partial pressure of dry air is
(a) 82.0 kPa
(b) 85.8 kPa
(c) 92.8 kPa
(d ) 90.6 kPa
(e) 72.0 kPa
41. The air in a house is at 20°C and 50 percent relative humidity. Now the air is
cooled at constant pressure. The temperature at which the moisture in the air will
start condensing is
(a) 8.7°C
(b) 11.3°C
(c) 13.8°C
(d ) 9.3°C
(e) 10.0°C
(e) 0 kg/s
(a) wet
(b) Superheated
(c) saturated
(d) Unsaturated
(a) Dew point temperature can be measured with the help of thermometer
(b) Dew point temperature is the saturation temperature corresponding to the partial
pressure of the water vapour in moist air.
(c) Dew point temperature is the same as the thermodynamic wet bulb temperature.
(d) For saturated air, dew point temperature is legs than the wet bulb temperature.
(a) increases
(b) decreases
(c) remains constant
(d) none of the above.
(a) decreases
(c) increases
57. The relative humidity, during cooling and dehumidification Of moist air
(a) increases
c) can increase or decrease
(b) decreases
(d) remains constant.