Professional Documents
Culture Documents
M2 PDF
M2 PDF
Note: This section consists of 10 questions. Each question carries ONE mark.
1) In limit state method stress in compression steel is based on?
A. Based on strain in concrete at its level
B. Modular ratio x stress in concrete at its level
C. Either of the above
D. None of the above
2) Deflection of doubly reinforced beams are ....compared to singly reinforced beams of same
depth
A. More
B. Less
C. Equal
D. None
3) A foot bridge has a slab of 3m width. The central supporting beam is of 6m length, width of
web = 250 mm. The effective width of flange is
A. 0.75 m
B. 1 m
C. 1.25 m
D. None
4) If neutral axis falls in the web and flange thickness less than 0.2d, and the section is balanced
the stress in the flange will be
A. Uniform and equal to 0.36
B. Uniform and equal to 0.45
C. Non – uniform
D. Uniform and equal to 0.416
5) A T- Beam with width of flange 740 mm; effective depth 400mm; width of web 240mm;
depth of flange is 100mm; reinforced with 4 bars of 20mm dia mild steel bars with M20
concrete. The ultimate moment of resistance is
A. 100 kN-m
B. 125 kN-m
C. 150 kN-m
D. 200 kN-m
6) If the depth of flange is the above beam is changed to 80 mm the ultimate moment of
resistance will be
A. 140 kN-m
B. 100 kN-m
C. 150 kN-m
D. 200 kN-m
7) A R.C. beam is simply supported at ends effective span is 6m. The maximum shear stress
developed in the concrete is 2 times the permissible value. The design shear reinforcement
shall be provided over a length of
A. Central 2m
B. Central 3m
C. Except central 3m every where
D. Entire length of beam
8) In a slab 12 mm diameter bars are to be provided at 200mm c/c as main reinforcement, due to
non availability the diameter of bars to be changed to 16mm the new spacing would be
A. 355.55 mm
B. 112.8mm
C. 300 mm
D. 450
10) A rectangular slab 4m x 6m supported on two opposite shorter edges should be designed as
A. A one way slab spanning along longer edges
B. A two way slab
C. A one way slab spanning along shorter edges
D. none
Note: This section consists of 2 questions. You have to give answer both the
questions in descriptive. Maximum marks are 5 (2+3) only
1. Give answer of below question in descriptively. (1+0.5+0.5 marks)
a) Derive the following equation:
• Determine the areas of steel, bar diameters and spacing in the two
directions or a simply supported slab of effective span 3.5 m x 8m
subjected to live loads of 4 kN/m 2 and the load of floor finish is 1 kN/m 2.
Use M20 and Fe 415. Draw the diagram showing the detailing of
reinforcement.
ANS:
1) A
2) B
3) C
4) B
5) A
6) B
7) C
8) C
9) D
10) A