Professional Documents
Culture Documents
TIMER OPERATION
Aulia El Hakim, S.ST.,M.T
PURPOSE
• Pembahasan Soal UTS !
• Pembahasan Soal Tugas !
• Memahami konsep Timer Operation pada Siemens S7-300
OUTLINE
TIMER OPERATION
HARDWARE PLC SIEMENS S7-300
MODUL Tipe ID Number
Power Supply ( PS) PS 307 2A 307-1BA01-0AA0
CPU CPU315-2DP 315-2AH14-0AB0
Digital input (DI) DI 16 X DC24 V 321-1BH02-0AA0
Digital Output (DO) DO 16XDC24V / 0.5A 322-1BH01-0AA0
Analaog Input (AI) AI 2X12BIT 331-7KB02-0AB0
Analaog Output (AO) AO 2X12BIT 332-5HB01-0AB0
HASIL UTS 3-A
HASIL UTS 3-B
HASIL UTS 3-C
Pembahasan Soal UTS !
Pembahasan Soal Tugas Note-8 /2!
• A trolley will move in the other direction if it stops in any end position and the start switch is excited. When
it warns the limit switch on the opposite side, it will return to the direction it came from. This movement will
continue until the warning of the start switch is removed. When the start switch is turned off, it will arrive at
its last location and wait there.
• Power failure, breakdown etc. If the car is left in the middle for reasons, it will continue in the same direction
as when the energy comes (use Non-volatile memory--- retain memory)
Detent
Switch
Solution
TIMER OPERATION
Size and range of the TIME data type
Note:The negative range of the TIME data type shown above cannot be used with the timer instructions. Negative PT (preset time)
values are set to zero when the timer instruction is executed. ET (elapsed time) is always a positive value.
Timer operations