Professional Documents
Culture Documents
3. Compilation
- Go to MAX+PLUS II, select Compiler.
- Go to Assign and select Device and choose the device type (e.g.
EPF10K20RC240-4) then click OK
- For timing simulation go to Processing and select the Timing
SNF extracor
- Go to the compiler window and press start
4. Simulation
a. Specify the stimulas and the output responses in the Simulation
Channel File ( e.g. mux.scf or adder.scf)
- Go to File select New and select Waveform editor file then
click OK
- Go to Node select Enter nodes from SNF
- Click the List button
- Select the input/output signals, then click OK
- You can specify your input signal values by clicking the right
mouse button and dragging it to the desired range.
- Go to File select SaveAs
- Enter the file name with a .scf extention and click OK
b. Simulation
- Go to MAX+PLUS II and select Simulator and click Start
- After the simulation is complete click the Open SCF button
d. Simulation range
- Go to File and Select Endtime
- Specify the simulation range and click OK
5. Programmer
a. Go to Assign menu and select Back-annotate project then
check "chips, pins, & devices" botton
b. Go to Assign menu and select Pin/Location/Chip then
specify signals to pins (the pin assignments are described in
6.)
c. Recompile your program
d. Programmer
- Go to MAX+plus II menu then programmer
- Go to JTAG menu and check Multi-device JTAG chain
- Go to JTAG menu and select Multi-device JTAG chain setup
- Select Device name and Programming file name (Flex: .sof,
Max: .pof) then add to device name and Programming file
name window
- Press Detect JTAG chain info botton (confirmed by
hardware check)
- Go back to Programmer window and press program for Max,
configure for Flex