Professional Documents
Culture Documents
5) Altimeter set to read airport elevation above sea level for landing and takeoff a) QFE b) *QNH* c)
SAS
6) Chime for capt. to get attention of cabin crew a) one high chime b) one low c) *Three high/low
chime*
7) In IFE map shown is a) shows aircraft altitude and distance b) shows origin and time to reach
destination c) taken from aircraft nav d) *all*
11).......... Light is used for illumination of individual instruments a) integral b) *pillar or bridge*
13) Altimeter has most sensitive a) Bourdon b) *Evacuated capsule* c) sealed capsules
15) mark correct regarding IMA a) it is cheaper b) c) stranded modules designed for unified
Equipment
17) dihedral of wing gives a) stability about longitudinal axis b) stability during roll c) direction d) *a
and b*
18) Engine parameters such as N1, RPM fuel flow are indicated on a) *upper ecam* b) lower ecam
19) ECAM function sypnotic is provided by a) SDACs b) FWCs c) DMCs d) Display unit
20) FMC is updated every - a) 28 days b) 28 days with 13 cycles per annum c) 28 days with 13
cycles per annum also aircraft weight and navigational data is also send along with it, also weight
should be filled in fmc before every flight
22) strobe light MTCS a) depends on size of the aircraft n positioned on wing tips supplement to
position light b) *maybe solely used as a beacon* c) 90 flash per min
23) Speaker location for PA a) cabin, galley b) option a + lav c) *option b + cockpit*
24) In large aircraft emergency power supplied by a) *emergency power pack + power from battery*
b) emergency power pack + emergency bus bar c) both
25) Cabin management system consists of a) Announcement b) airstairs if installed c) Audio video
and IFE d) *all*
26) Taxi n landing light has relay solenoid a) *has high wattage* b) faster in ops c) used for less time
27) lapse rate at absolute pressure a) 6.5 * K per kilometer b) 8.5* K per kilometer c) none
28) AFDX is latest technology to transfer data in a very short duration upto a) 10 million bps b) 100
million bps c) 1 million bps
29) In integral fuel tank use of sealent is kept minimum because to a) avoid fuel contamination b)
reduce weight c) provide ventilation fuel tanks
30) Vertical stabilizers can be located which station a) butt b) water c) datum d) none
31) chocks should be positioned at a) aft of wheel b) front of wheel c) aft and front both d) anyone of
the above
32) If aircraft is parked a) only external covers n securing is required b) internal securing by gust locks
on throttle and controls be used c) *both*
33) In Adiabatic cycle a) temperature increase pressure remains constant b) temperature decreases
at constant volume c) both a and b d) *no transfer of heat from outside to inside takes place*
36) Rib in wing a) gives wing cambered shape b) leading edge to training edge c) takes load
40) Emergency operation of LG a) extension down lock by mechanical means b) extension down n
lock of l.g without pneumatic, Hydraulic, electrical power c) as in option b and can be retraction back
41) which type of oxygen is not used in civil aircraft a) *liquid type* b) gaseous type c) type I d) a and
b
42) Negative static stability a) if object is disturbed it will resist and come back to its original position
b) if object is disturbed it tends to continue in the direction if disturbance c) if object is disturbed the
object is followed to continue in direction of disturbance
43) Engine Nacelle firewall material a) made up of stainless steel b) as in option a and Aluminum
sometimes c) *as in option A and in some aircraft Titanium*
A) Stick Shaker
B) Stick Pusher
C) Sensor
47.Speed break is a
A . movable control surface
B.fixed control surface
C.both a and b is correct