Professional Documents
Culture Documents
(Reaffirmed 2017)
en
se
om d
eg to
ac Ar
on un
su Ku
lta m
nt ar
@ Da
gm s
ail
.co
m
( Reaffirmed 2003 )
IS : 6241- 1971
Indian Standard
METHOD OF TEST FOR
DETERMINATION OF STRIPPING VALUE OF
ROAD AGGREGATES
Members
SHRI K. K. ADRAWALA Builders’ Association of India, Bombay
m
SWRI K. K. MADHOK ( Alternate )
gm as
SHRI T. N. BHAROAVA Ministry of Shipping & Transport
.co
CHIEF ARCHITECT Central Public Works Department ( Architectural
Wing )
nt@ ar D
SHRI G. C. Das National Test House, Calcutta
ail
SHRI P. R. DAS ( Alternate )
DR M. P. DHIR Cent;)ralh,Road Research Institute ( CSIR ), New
um
(Alternate)
SHRI M. L. SETHI Department of Geology & Mining, Government of
Rajasthan
om
Lic
( Continued on page 2 )
( Continuedfrom Page 1 )
Members Representing
SUPERINTENDING ENGINEER Public Works Department, Government of Tarnil
( DESIGNS& MARINE WORKS ) Nadu
DEPUTY CHIEF ENGINEER( I & D )
( Alternate)
&RI S. V. SURYANARAYANA Central Water & Power Commission, New Delhi
SHRI M. V. YOGI Engineer-in-Chief’s Branch, Army Headquarters
( Ministry of Defence )
SHRI K. N. SUBHAKAO ( Alternate )
SHRI D. AJITHA SIMHA, Director General, IS1 ( Ex-o&icio Member )
Director ( Civ Engg )
m
SHRI K. M. MATHUR
gm as
Assistant Director ( Civ Engg ), ISI
.co
nt@ r D
ail
lta uma
nK
ru
oA
su
on
dt
ac
se
eg
en
om
Lic
2
1s : 6241-19’31
Indian Standard
METHOD OF TEST FOR
DETERMINATION OF STRIPPING VALUE OF
ROA’D AGGREGATES
0. FOREWORD
3.1 This Indian Standard was adopted by the Indian Standards Institu-
tion on 24 September 1971, after the draft finalized by the Stones
m
Sectional Committee had been approved by the Civil Engineering
gm as
Division Council.
.co
nt@ ar D
0.2 The road system in the country is developing at a fast rate and, as a
result, the old sources of road aggregates with proven performance
ail
characteristics arc getting fast depleted. Newer sources of aggregates,
performance records for which are not yet available, are thus being
um
established. This standard has been mepared to lav down the method of
test for the property of adhesion Af aggregates ‘with different types of
bituminous bin-eat surtablhty of aggregates could be ascertained.
nK
-
0.3 In the formulation of this standard considerable assistance has been
rendered by Central Road Research Institute, New Delhi, who has
ru
su
1. SCOPE
1.1 This standard covers the procedure for determining stripping value by
eg
en
2. PROCEDURE
2.1 Retain on 12*5-mm IS sieve 200 g of aggregates passing 20-mm IS
sieve. Dry, clean and mix with 5 percent binder by weight of aggregates
in a small casserole, binder being heated previously to 160°C if bitumen
and 110°C if tar. The aggregates are also to be heated prior to mixing
3
IS : 6241- 1971
3. EVALUATION
3.1 The stripping value shall be the ratio of the uncovered area observed
visually to the total area of the aggregates in eaeh test expressed as a
percentage.
m
gm as
4. REPORTING OF RESULT
.co
4.1 The mean of the three results shall be reported as stripping value of
nt@ r D
the tested material and shall be expressed nearest to whole number.
ail
lta uma
on un K
r
oA
su
om ed t
ac
ns
eg
e
Lic