Professional Documents
Culture Documents
Rear end
19-Fuel pump
3. Tightening Torque and Method of Main Bolts of M26 Series Diesel Engine
3.1 Main bearing bolts and secondary bolts of main bearing cap
3.1.1 Before tightening, apply lubricating oil on the thread portion and pressure-bearing
surface.
3.1.3 Tighten the bolts in two times according to the sequence (from A to N) shown in fig 1.
3.1.4 Tighten all secondary bolts of main bearing cap alternatively in two times according to
the same sequence until the final tightening torque reaches 270Nm. (Only for 12M26 series
diesel engine).
Front end
Figure 1
-4-