This document discusses settings for temperature measurement and RTD ohm measurement in 3 sections:
1) Setting the temperature of the cold junction compensation box between 0-99°C with a default of 23°C.
2) Setting an offset value for the measurement range between 0-9999 ohms to offset the beginning of the range when using a sensor in a measuring head, with a default of 0 ohms.
3) Enabling compensation of 2-wire conduct by confirming "YES" and short-circuiting the sensor end of the conduct for accurate measurements when using a 2-wire connection, with a default of no compensation.
This document discusses settings for temperature measurement and RTD ohm measurement in 3 sections:
1) Setting the temperature of the cold junction compensation box between 0-99°C with a default of 23°C.
2) Setting an offset value for the measurement range between 0-9999 ohms to offset the beginning of the range when using a sensor in a measuring head, with a default of 0 ohms.
3) Enabling compensation of 2-wire conduct by confirming "YES" and short-circuiting the sensor end of the conduct for accurate measurements when using a 2-wire connection, with a default of no compensation.
This document discusses settings for temperature measurement and RTD ohm measurement in 3 sections:
1) Setting the temperature of the cold junction compensation box between 0-99°C with a default of 23°C.
2) Setting an offset value for the measurement range between 0-9999 ohms to offset the beginning of the range when using a sensor in a measuring head, with a default of 0 ohms.
3) Enabling compensation of 2-wire conduct by confirming "YES" and short-circuiting the sensor end of the conduct for accurate measurements when using a 2-wire connection, with a default of no compensation.
INPUTS CLEAR READ. /S 23. 0 - range 0…99°C with compensation box
- DEF = 23°C CHANNE. CONFIG. TYPE OUTPUT. RTC MODE SERVIC. EXT. IN. CONECT. KEYS C. J . TEM.
6.1.2f ZERO OFFSET OF THE MEASUREMENT RANGE RTD OHM
AD. RES. Offset of the beginning of
the measuring range
INPUTS CLEAR READ. /S 0. 0 - in cases when it is necessary to offset the
beginning of the range by certain value, e.g. CHANNE. CONFIG. TYPE while using sensor in measuring head - entered directly in Ohm (0…9999) OUTPUT. RTC MODE - DEF = 0 SERVIC. EXT. IN. CONECT. KEYS AD. RES. LEADS
6.1.2g COMPENSATION OF 2-WIRE CONDUCT RTD OHM
LEADS Compensation of 2-wire conduct
INPUTS CLEAR READ. /S YES - for measurement accuracy it is necessary to
perform compensation of conduct always in CHANNE. CONFIG. TYPE case of 2-wire connection - prior confirmation of the displayed prompt “ YES“ OUTPUT. RTC MODE it is necessary to substitute the sensor at the end of the conduct by a short-circuit SERVIC. EXT. IN. CONECT. - DEF = 0 KEYS AD . RES. LEADS