Operating Instructions: KX-TS520MX
Operating Instructions: KX-TS520MX
1-A Controls 2-A Making calls 3-B Dialing a stored number 5-A Wall mounting 5-C For your safety
Operating Instructions Memory sticker DIALING MODE 1 Lift the handset and dial the phone number. To redial the last number dialed 1 Lift the handset. 1 Press the tabs in the direction of the arrows 3 Drive screws (not included) into the wall To prevent severe injury and lost of life/ 1. Do not use this product near water, for example,
selector Lift the handset Press {REDIAL}. (), then remove the wall mounting adaptor using the wall template below. Connect the property, read this section carefully before near bathtub, washbowl, kitchen sink or laundry
Integrated Telephone System 2 When you finish talking, place the handset {REDIAL} will dial the last number you called 2 Press the one-touch auto dial button {M1}, {M2} or {M3}.
(). telephone line cord. Mount the unit and then using the product to ensure proper and safe tub, in a wet basement or near a swimming pool.
Ringer indicator RINGER selector on the cradle. 2. Avoid using a telephone (other than a cordless
manually, not a One-Touch Dialer number (3-B). {REDIAL} does not work for One-Touch Dialer. slide it down. operation of your product.
Model No. KX-TS520MX PQRS
7
4
GHI
TUV
1 2
5 6
3
JKL
ABC
MNO
DEF
FLASH
PROG
RAM
M2
M3
M1
9 PAUS
M2
If the telephone line cord is disconnected more than 3 days, the stored numbers may be erased. DATA To prevent the risk of fire or electrical shock, do 3. Do not use the telephone to report a gas leak in
0
Press {} or {} repeatedly while talking.
E
TONE M3
VOLU
VOLUME {}, {FLASH} After hanging up, the volume level will be saved. Store phone numbers again, if necessary. not expose the product to rain or any type of
{} moisture. SAVE THESE INSTRUCTIONS
8.3 cm
Do not disassemble the product.
{PAUSE} {PROGRAM}
M1
M2
M3
Environment
Do not spill liquids (detergents, cleansers, etc.)
{*} {TONE} 2-B Answering calls 4 Special Features 2 Tuck the telephone line cord inside the onto the telephone line cord plug, or allow it The product should be kept free from excessive
smoke, dust, high temperature, and vibration.
Hooks to become wet at all. This may cause a fire.
Accessory information wall mounting adaptor, and push it in the To single-line The product should not be exposed to direct
When a call is being received, the unit rings, The ringer indicator will flash when If the telephone line cord plug becomes wet,
direction of the arrow. telephone jack sunlight.
Handset . . . . . . . . . . . . . . . . . one a telephone number is dialed in PULSE mode, 4-A For call waiting service users immediately pull it from the telephone wall jack,
the ringer indicator flashes quickly. You can The word “UP WALL” should face upward. (LINE)
and do not use. Do not place heavy objects on top of the product.
Handset cord . . . . . . . . . . . . . one answer the call by simply lifting the handset. or
Telephone line cord . . . . . . . . one someone picks up or hangs up another phone To communication The product should be kept away from heat
To use call waiting, you must first subscribe to the call waiting service of your service provider/ CAUTION
Please read these operating instructions before connected to the same phone line. device (DATA) sources such as radiators, cookers, etc. It should
This is normal. telephone company. This feature allows you to receive calls while you are already talking on the Never install telephone wiring during an electrical not be placed in rooms where the temperature
using the unit and save them for future reference.
phone. If you receive a call while on the phone, you will hear a call waiting tone. storm. is less than 5°C or greater than 40°C. Damp
Never install telephone line jacks in wet locations basement should also be avoided.
1 Press {FLASH} to answer the 2nd call. To temporarily set the unless the jack is specifically designed for wet
Routine care
1-B Connections 3 One-Touch Dialer 2 To switch between calls, press {FLASH}. handset down during a
conversation, place it as
locations.
Wipe the outer surface of the product with a
Never touch uninsulated telephone wires or
shown here. soft moist cloth.
Note: terminals unless the telephone line has been
LINE DATA 1 Connect the handset cord () to the handset Do not use benzine, thinner, or any abrasive
For your future reference 3-A Storing phone numbers in memory Please contact your service provider/telephone company for details and availability of this service in your disconnected at the network interface.
powder.
We recommend keeping a record of the following and the unit. Connect the telephone line area. Use caution when installing or modifying
information to assist with any repair under warranty. Handset cord until it clicks into the unit and telephone You can store up to 3 phone numbers in the telephone lines. Notice for product disposal, transfer, or
line jack (). After line connection, lift the If you misprogram 5-B Troubleshooting Important safety instructions return
M1
M2
M3
one-touch auto dial buttons {M1}, {M2} or Hang up Restart from step 1. 4-B Temporary tone dialing (for rotary/pulse service users)
Serial No. handset to check for a dial tone. When using your product, basic safety precautions This product can store your private/confidential
{M3}. Do not press any one-touch auto dial Problem Cause/solution
(found on the bottom of the unit) should always be followed to reduce the risk of fire, information. To protect your privacy/confidentiality,
buttons before storing to prevent misoperation. To erase a stored number
2 Set the DIALING MODE selector to TONE. You can temporarily switch the dialing mode to tone when you need to access touch-tone The unit does not work. Check the connections (1-B). electric shock and injury to persons, including the we recommend that you erase the information
Lift the handset Press {PROGRAM} following :
Date of purchase Telephone If you cannot dial, 1 Lift the handset Press {PROGRAM}.
the one-touch auto dial button {M1}, {M2}
services (for example, answering services, telephone banking services, etc.). Press {*} {TONE} The call cannot be connected Check whether the DIALING MODE selector setting is correct or not
such as one-touch dialer from the memory before
line cord set to PULSE. you dispose of, transfer, or return the product.
2 Press the one-touch auto dial button {M1}, or {M3} of the phone number to be erased before entering access numbers which require tone dialing. even if you dialed correctly. (1-B).
Name and address of dealer TONE PULSE
DIALING MODE {M2} or {M3}. {PAUSE} {PROGRAM} Hang up. The unit does not ring. The RINGER selector is set to OFF. Set to HIGH or LOW (1-B).
4-C Pause (for PBX/long distance service users) 5-D Specifications
To single-line Handset cord
3 Set the RINGER selector to HIGH, LOW or OFF.
3 Enter a phone number up to 21 digits. Memory sticker You cannot store a phone Confirm the handset is off the cradle.
telephone jack number in memory. Do not enter a phone number more than 21 digits long, or the
(Example : “HIGH” is selected.) 4 Press {PROGRAM}. Use the memory sticker as a name or Power Source: From telephone line
A pause is sometimes required when making calls using a PBX or long distance service. entered number and the previously stored number will be cleared.
When set to OFF, the unit phone number index for the stored numbers. Dimensions (H x W x D): Approx. 95 mm 190 mm 196 mm
5 Example: If you need to dial the line access number “9” when making outside calls with a PBX:
Attach your purchase receipt here.
will not ring but the ringer RINGER When finished, hang up. The other party suddenly {PROGRAM} was pressed during the conversation. Press {PROGRAM}
Mass (Weight): Approx. 518 g
indicator will still flashing. HIGH OFF If a pause is required for dialing, press 1 Lift the handset to start calling. cannot hear your voice during
a conversation.
again.
Operating conditions: 5°C–40°C, 20 %–80 % relative air humidity (dry)
LOW {PAUSE} in step 3. A pause stored in a phone
number counts as one digit (4-C). 2 {9} {PAUSE} You cannot redial by pressing If the last number dialed was more than 31 digits long, the number Note:
M1
M2
the handset and telephone line cord, connect the communication device telephone line cord to telephone line cord.
pauses. This material is copyrighted by Panasonic Communications (Malaysia) Sdn. Bhd., and may be
the DATA jack. Wall Template reproduced for internal use only. All other reproduction, in whole or in part, is prohibited without
Make sure the communication device is not in use before using this unit (making calls, storing phone the written consent of Panasonic Communications (Malaysia) Sdn. Bhd.
numbers in memory etc.) or the communication device may not operate properly. 8.3 cm
PNQX1078ZA FM0908SS0 © 2008 Panasonic Communications (Malaysia) Sdn. Bhd. All Rights Reserved.
9
5 6 MNO RAM
{REDIAL}
PQRS
ß ö}_> ø ºphýn=}gT ÓnY{É Ôí{A íÌ x}"Ð }]B
fC (ÒlvW À) èl`F÷Ï Úle> ÒÈ vy]S
7
DATA 8
TUV
WXYZ
FLASH M1
p
.pi ö~CÐ ênSÚúÐ yY x {S ºênxÌ p?Ć? Y }Tú >n4Ð B dH [R > ÐÙÐ p
9 M2
{M3}º{M2}º{M1}
PAUS
0 E
H ø¾ .ÒÚíUÐ {fL ºî}BÐ Ò}Y >Ð4Ð ênSÚÌ x~= S {}º{} Ó[UÐ
Ò3fb]SÏ ëz' _?Ï .sfCÐ hca> OÐ {e_> ø p .#Ð énaSÎ {_= Ó[UÐ îY x~ĺ hH p
{FLASH} bk 4 M1
nÈl@ ÒÏ|f* ¾
DL (zUÐ h^fUÐ ýÐHí ÓÐ}g]CÐ) ýÐUÐ oc> ø
M2
nýfSÏ
M3
p {PROGRAM} bl {PAUSE} 5
Ún`UÐí ënB{UÐ Y {ýÐ~UÐ Ú{bUÐ L Ð ð{h_= sfCÐ Ênb=Ð `fx p DL nðJÚ y[x ëj= U ye> íÌ º>n4Ð B dH =nS DL ohTGUÐ é ö7 BÐØ >n4Ð B dH
he= S ¼
ÒlAlaAÏ BJ ×{SÏ Ð-¼
ÓnRn]B {TONE} {*} 6 ndcZAÏ ÒlfS3aSÏ
.ÛÐ~wøÐí phUn_UÐ ÒÚÐ}"Ðí .x}A ÑZf= Ð|w ox {bR .çĆJüÐ B bY OÐ .gUÐ ìn9Ð : _RØÐí ÚÐ{!Ð {fL Ü}!Ð kY YhH p Ü}!Ð kY Yx ºÛng!Ð ë}x ºpCncY êĆHÐ x nY{fL
.Ò nCÐ eZUÐ p_Iú sfCÐ ß}_x ø ëÌ `fx Y ÚaUÐ DL = S ºðĆdY >n4Ð dH =nS yÉÌ ÐÙÐ ïØnAÐ >nw .DLÌ OÐ pgY “UP WALL” ÒÚn_UÐ ëc> ëÌ `fx p í{@Ë nAlaW Ùl\gÏ nWy@ WyA Ë-¾ {AÐí . . . . . . . . . . . . . . . . . pL 5UÐ t
p íÌ ºPULSE ĿfUÐ
UÐ : >nw S}= én[>øÐ - .pL 5UÐ
RÚ Ø}e= pCncCÐ DL Ø}UÐ fcex .pL=
.sfCÐ DL pdhbUÐ ÊnhIúÐ
í OÎ {e_> ø p .U5_Hn= b> øí º>n4Ð B bY (LINE)
af= ÉY
ö }BË >nw abx íÌ w{AÌ oh« nY{fL - {AÐí . . . . . . . . . . . . . pL 5UÐ dH t
ºÓÐGxØÐ}UÐ Y ÒÚÐ}"Ð ÚØn[Y L Ð ð{h_= sfCÐ bx ëÌ o« fd< (DATA) én[>üÐ Ûng@ OÐ .= pÉn#Ð >n4Ð pT /pY{#Ð ê{bY Y pCncCÐ Ún^iÐ pY{B : èGZ> ëÌ pð xÐ{= hdL o« ºpCncCÐ Ún^iÐ é5_Hø {AÐí . . . . . . . . . . . >n4Ð B dH t
p .>n4Ð B è3]FÏ Q ëzu f^XSÏ Ò3fb]< ÑÉÏ{Q >{v
p@ÚØ ëc> UÐ æ}`UÐ : _í ê{L `fx .zUÐ z]CÐ {SÐY pe`i
eH ilR º>n4n= Ô{UÐ Ênf?Ì pCncY qedHÐ ÐÙÐ .>n4n= ?{Ļ Ênf?Ì ÓnCncY êĆHÐ Ò~hCÐ ì|w U yh>
.px{LÚ paÉnL éĆB >n4Ð èĆHÌ ohT}> OÐ Ð ð{=Ì {e_> ø p ._hJ Ð|w .ï¯`W lefSÏ á>{bS l' _?Ïì ÚleÏ
.pxþY p@ÚØ ¿» Y DLÌ íÌ pxþY Ón@ÚØ À Y SÌ n*ÚÐ}A 3 nY pddY TnYÌ : >nw B =nbY ohT}> OÐ Ð ð{=Ì {e_> ø p
.pCncCÐ Ún^iÐ
.ßÚúÐ qĻ p_SÐUÐ pJ}UÐ =Ð]UÐ ïØna> n\xÌ ð o«í .pddCÐ TnY±U n[h[B
ð e[Y bCÐ cx
cZ= nðin@ pL 5UÐ
U .phinUÐ pCncCÐ DL p=n@³U {FLASH} `Î »
nfdf<ìÙ nvldJ æÐ}JÌ íÌ éÛnL ëí{= >nw èĆHÌ C OÐ Ð ð{=Ì {e_> ø p
w 5T ng_ ºp?ØnCÐ Ênf?Ì qSkY
.nfw NY .{FLASH} `Ð ºÓnCncCÐ N= x{dU ¼ Ñy?Ïì ncb; èlY<Ï ½ Ò¯fÈSÏ Ð-»
.ncJlg nHÙ Ü3Q n][`; qdAÏ W >Ùl!Ï w[SÏ wc; Q p =Ú y]H Y pU[aY >n4Ð à]B c> 3 nY hÉ>
S .Ûng!Ðí pL 5Un= (1) pL 5UÐ dH hÉ= S »
.phHnS hAnY ïÌ íÌ }fUÐ íÌ x~fUÐ e_> ø p .pcZUÐ :n\?¯W Ñ{RÏzSÏ 8
<l2Ï élQÙË v|Ġ Ë-½ bYí Ûng!Ð : ]fx ëÌ OÐ >n4Ð B dH hÉ=
LINE DATA
¯ï `W lefSÏ á>{SÏ acv ÒlWb]W
.>n4Ð à]B x{_> íÌ ohT}> {fL iÐ p .b]fY : pY{#Ð ì|w }R>í hÉnaUÐ pR}_C = pÉn#Ð >n4Ð pT /pY{#Ð ê{be= én[>üÐ @}x p ïj= Ò{LnedU phUnUÐ ÓnYd_CÐ Y pf= ánaAøn= ļi
Jl>ÙÍ ìË b`g ìË qdAÏ W bSÏ è? n\?¯W ?¯ÈÍì ºhÉUÐ {_= .pbJ ÓÉ Úí{É
Y (2) >n4Ð B
nWlu nW¯F Ò3fb]< ?¯ÈÍìb!Ï
b!Ïîîõ{ġ
õ{ġ Ð -¿
Ð-¿ n4DSÏ 8 Òh[@Ë ÏØÍ én[>üÐ ÚÐÚÛÌ : >nw ênSÚÌ ¾ OÎ [x nY x~ĺ fcex pL 5UÐ .pi5\dU
nB yhd[>
pÉnB px/pÉnB ÓnYd_Y x~= sfCÐ êbx {S .én[>üÐ pe`i Y {TjdU pL 5UÐ
RÚÐ
(kdSÏ/£{`SÏ
<l2Ï nWy@ WyA) oQiAÏ c^dSÏ èlY<ûÏ Ð -¾ ø .{M3} íÌ {M2} íÌ {M1} Ò{AÐí ped= ýnbdUÐ
p
Ónghf> _= ân>Î nðYíØ o« º= Þn#Ð sfCÐ é5_HÐ {fL .¼ Ò]#Ð Y î}BÌ Ò}Y Ì{=Ð ➡ #Ð aSÌ
M3
¼
M2
M1
ye= êb> ëj= ļi ºx/hÉ[B px5" .= Ï /mSÏ nbaXAÏ x~UÐ S Ò{AÐí ped= ýnbd> én[>Î ÚÛ ïÌ `\> .TONE e`fUÐ
UÐ DL DAILING MODE ÖnaCÐ Ð MdUÐ S}UÐ
êb> ëÌ S Ò}TÐ|UÐ Y Ò{AÐí ped= én[>ünT ÓnYd_CÐ âSíí x}"Ð }]B hdbU phHnHúÐ phJnhAøÐ pYĆUÐ ºénCÐ hH DL) phe`i-pC ÓnY{B é5_HÐ {x}> nY{fL qSkY cZ= e`fUÐ OÎ én[>üÐ
í x{> fcex
.(Ñ-¼) ÓĆÉUÐ Y bĻ p .c]v ÷ ÚleÏ ê õ|6 QÙ wA .ÿJn#Ð h`ZUÐ
fC ]Ð ºS}UÐ odJ Y ce> 3 ÐÙÐ p (Ûng!Ð ânS DL {@x)
.Ln@ÚÎ íÌ dbi íÌ sfCÐ Y dUn= :Mx nY e\x 5= ºph[ZUÐ Ón=nÉüÐí phýn=}gcUÐ ÓnY{[UÐ éÉUÐ ênSÚÌ énBØÎ S {TONE} {*} `Î .(zUÐ ºpha>n4Ð phRWCÐ ÓĆYn_CÐ ÓnY{B ºÓnCncCÐ DL Ø}UÐ ÓnY{B B dH
➡ {PROGRAM} `Ð ➡ pL 5UÐ
RÚÐ 2
.(Ñ-¼) ø êÐ phÉ DIALING MODE ÖnaCÐ pþh* qinT ÐÙÐ n, bĻ p W O{SÏ BJ nAlaAÏ fÈ< acv ÷
.e`i én[>Î od]> UÐ .{PROGRAM} `Ð ➡ pL 5UÐ
RÚÐ » .PULSE ĿfUÐ
UÐ DL
>n4Ð
1
.nfÈ n`v{[; Q{SÏ mb[; WlfQ {M2} íÌ {M1} Ò{AÐí ped= ýnbdUÐ én[>üÐ ÚÛ ➡ TONE PULSE ÊÐPUÐ zxÚn>
Òl_ÈÏAÏ ×-¿
UÐ DL ]Ð .OFF ænbxüÐ
í DL jhgY RINGER Ü}!Ð ÚnhBÐ ÖnaY .ÚleÏ ê{v ÷ ➡ Y ØÐ}CÐ >n4Ð S}U {M3} íÌ íÌ {M1} Ò{AÐí ped= ýnbdUÐ én[>üÐ ÚÛ `Ð ¼ DIALING MODE
p
Y ph]B pbRÐY ëí{= âf, ý~!Ð íÌ McUÐ ÕniüÐ
h+ .bR MBÐ{UÐ é5_HĆU ng@niÎ ÒØnLÎ ÙÏyÏ BJ mfRESÏ [6
.éJÌ qSkY ºÒ}TÐ|UÐ : >Ðw ênSÚÌ x~ĺ ºÓøn[>Ð ÊÐ}@Î ) Ûng!Ð Ð|w é5_HÐ S é5_HøÐ {hS én[>øÐ Ûng@ ëcx øÌ DL Þ}AÐ p
.Panasonic Communications (Malaysia) Sdn. Bhd.
H ø¾ ò
.yhÉ cZ= én[>üÐ Ûng@ e_x U øÎí (zUÐ
.pKa7 çb"Ð
h+ © 2008 Panasonic Communications (Malaysia) Sdn. Bhd.