Professional Documents
Culture Documents
Commands used –
1. Sketch
2. Revolve
3. Extrude Boss
4. Circular pattern
5. Rotate
PROCEDURE:
1. Select the front Plane-Sketch the profile as shown in figure to create shaft. Total
shaft length is 370mm.
3. The staging for the Compressor blades are 40mm and 140mm from the point of
origin.
5. Sketch the profile for the first and second compressor stage with new plane
height of 80mm, with a chord length of 20mm.
6. Loft the surface and twist the blade with 40degrees twisting.
1
5.b) MODELLING OF TURBINE
1. The staging for the Turbine blades are at 300 mm from the point of origin.
3. Sketch the profile for Turbine with new plane height of 80mm, with a chord length
of 20mm.
4. Loft the surface and twist the blade with 40degrees twisting.
RESULT :
Figure : 2D Shaft