Professional Documents
Culture Documents
Load Combinations
This kind of bearings can carry very high loads, over
50.000 kN Concrete and elastomer pressure
According to EN 1337-5 the allowable concrete
The bearings are designed for combined maximum pressure depends on the relative dimensions of the
vertical and horizontal loads. The standard range of bearing structure interface to the total support area
Agom pot bearing is designed to have an horizontal Guided sliding devices are identical in construction to
free sliding bearings but are also fitted with one or and the characteristic strength of the concrete.
load ≤ 15% of the maximum vertical load with a
maximum rotation of ± 0.01 rad (other load and more guides to limit the bearing’s movement to only
rotation combinations are provided on request). one direction.
AAG | Aalborg Gummivarefabrik A/S | Sundsholmen 3 | DK-9400 Nr. Sundby | Phone +45 98 15 80 22 | info@aag.world | aag.world 1
AGOM POT BEARINGS EN-1337-5
v-max series - distributed by aag
Friction of the bearings Ferrous material for pot and piston: The standard corrosion protection according EN 1337-
9 is as follows:
The reaction of the bearing to the movement can be The pot, the piston and if applicable the sliding plate
mathematically calculated by considering friction
coefficient between stainless steel and PTFE to be
are manufactured from ferrous material in accordance sandblasting SA2.5 grade
with EN 10025 standard.
0,03.
twocomponents high thickness epoxy zinc paint:
The exact friction coefficient between stainless steel Austenitic steel sheet 250 µm
and PTFE is determined in according to EN 1337-2.
The austenitic steel used for The high resistant corrosion protection (cycle for C5 M-
Quality sliding surfaces is X5CrNiMo17- H environment) is as follow:
12-2 in accordance with EN
Agom V-Max bearings are designed and manufactured 10088-2 1.4401 with a sandblasting SA 2.5 grade
in accordance with the requirements of the new minimum thickness of 1.5 mm.
European standard EN 1337-5 and have the
qualification of the CE mark. Agom can also supply pot The roughness is Ry5i ≤ 1 μm.
zinc rich epoxy primer (DFT ≥75 µm)
bearings complying with other standards. Every single
component is mechanically worked and assembled by The hardness ≥ 150 HV1 and ≤
sealing: Epoxy mastic intermediate (DFT ≥175 µm)
fully qualified and trained workers at the Agom 220 HV1.
factory with regular external inspections according to top coat: Polyurethane paint (DFT ≥75 µm)
EN 1337 and under strict ISO 9001:2015 quality
control standards. PTFE
Comprehensive Labelling
Agom uses only virgin PTFE
without regenerated or filler All the bearings are provided with a metal label
materials. detailing the proprieties of the bearings: