LVANIA
MECHANICAL DATA
Bulb Tr
Base 7-1, Miniature Button, 7-Pin
Outline 5:2
Basing 40K
Cathode Cod
Mounting Position ‘Any
ELECTRICAL DATA
RATINGS (Absolute Values) 60 Cycle Supply
Peak Anode and Starter Electrode Voltage
Tverse a 200
Forward 200
Cathode Current
Peak 100
Average! 25
Peak Starter-Blectrode Curcent
with Starter-Electrode Positive 100
Ambient Temperacure “00't0 +75
CHARACTERISTICS
Conditions:
Inscancaneous Anode Voltage 185
Peak Positive Starter Electrode
Prefiring Voltage 70
Peak Positive Starter lecttode
Triggering Voltage 50
Anode Circuit Series Resistance 820
Srarter-Electrode Series Resistor 100,000
Ionization Time 20
Deionization Time 300
Anode Voltage Drop 68
Starter Electrode Voltage Drop 6
Anode Breakdown Voltage 290
Starter Bleccrode Breakdown Voltage 8%
Required Transfer Current (DC of AC
For Transition of Discharge t0
‘Anode at 140 Volts Peak 30
TYPICAL OPERATION
Relay Service with 60 Cycle AC Supply
AC Anat Supply Voltage (RMS) u7
AC Suirter Hlectrode Voltage
Maximum Peak Positive Pre-Fiting Voltage 70
Minnaim Beak Pusitive Triggering Voltage 35
Muntoues Firing Voltage: (Sum of In-Phase
Ivantaneaus Pre-Firing Voltage And
Inscascanernis Triggering Voltage 105
vid uner any interval of 15 seconds maximum,
Volts
Volts
Ma
Ma
Ma
c
Voles
Volts
Volts
Ohms
Ohms
Volts
Voles
Volts
Volts
samp
Voles
Voks
Vols
Volts
engineering data service
Max.
Max,
Max.
Max
Max.
Max,
‘SYLVANIA
9823
QUICK REFERENCE DATA
‘The Sylvania Type 5823 is a cold
cathode, gas filled triode designed
primarily for operation as a relay
control tube.
ry
SYLVANIA ELECTRIC
PRODUCTS INC.
RADIO TUBE DIVISION
EMPORIUM, PA.
Prepared and Relenied By TheSYLVANIA
9823
PAGE 2
APPLICATION DATA
“The 5823 may also be used as a rectifier. When so used (with starterelectrode connected through 50,000-Ohm
resistor to anode), the 5823 has a maximum peak inverse anode voltage rating of 200 voles, a maximum peak
cathode current of 100 milliamperes and a maximum dc cathode current of 25 milliamperes. Operation at values
of de cathode current less than 8 milliamperes is not recommended because of resulting instability
AVERAGE ANODE CHARACTERISTICS
ANODE VOLTAGE (OC OR INSTANTANEOUS AC)
ANODE CURRENT IN MA (OC OR INSTANTANEOUS AC)ANODE VOLTAGE (DC OR INSTANTANEOUS AC)
SYLVANIA
9823
PAGE 3
BREAKDOWN CHARACTERISTICS
STARTER-ELECTRODE SERIES RESISTANCE *200000 OHMS
an RANGES SHOWN BETWEEN INSIDE AND OUTSIDE CURVES TAKE HH
INTO ACCOUNT MAX. AND MIN. + AND — VOLTAGE VALUES FOR
INDIVIDUAL TUBES AND FOR CHANGES DURING TUBE LIFE.
THE VALUES SHOWN BY DASHED SECTIONS ARE APPROX. ONLY.
‘STARTER TO CATHODE.
uN queens Or
i “|
STARTER-ELECTRODE VOLTAGE (DC OR INSTANTANEOUS AC)
|
|
i
i
J
Cae NOT_RECOMME
aSYLVANIA
9823
PAGE 4
TRANSITION CHARACTERISTICS
ANODE VOLTAGE (DC OR INSTANTANEOUS AC)
400
300
200
100
MAX. INDIVIDUAL TUB!
VALUES DURING LIF!
AVERAGE INDIVIDUAL
INITIAL-TUBE VALUES
200 400 600 800
STARTER-ELECTRODE CURRENT IN JLA (DC OR INSTANTANEOUS AC)
1000