Name: CUBAL, SHEM MISHAEL s. Date: FEB. 5 202)
Subject STRDES 4
Quiz 1
INTRODUCTION TO STRUCTURAL STEEL DESIGN
Write the answer that best describe the following items on the space provided before the number and loop it
on the table presented. (2 points each)
1. It is a property of steel and if itis not present the material will break if sudden
ucnury. Joad is applied.
2. It is an advantage of steel as a structural material compare to reinforced
UNIFORMITY. _ooeiaes
COLD FORMED STEEL 3. Itis a steel usually used for ight members in roof, floors and walls.
TOLEHNESS 4. Itis a property of steel that can withstand a large number of forces.
PROPORTIONAL LIMIT 5. Itis the most important property of steel to the designer and itis the first point
cn the stress strain diagram where tangent to the curve is horizontal
COPPER. 6. Itis usually used as an anti-corrosion component of steel.
Fae 7. It causes a large number of structural failures.
. It is a source of failure due to the insufficient bearing or anchorage on beams.
INS 8. ilure d th
YIELD STRESS. 9. It must be considered in designing without sacrificing the strength of the
‘structure.
‘ERECTION PROELEMS 10. It is a problem due to inadequate attention to deflections, fatigue of
members, bracing against swaying, vibrations and the possibility of buckling of
‘compression members
HOT RELLED “STE 11. This is done while steel is still hot to allow it to be deformed with no
resulting loss in ductility.
TEE 12. Itis obtained by splitting a W steel section.
Wet