Professional Documents
Culture Documents
Job Order No.: 21-3-23 Certificate No.: F1013/21 Issued Date: 25-Jan-21
Customer Data
Company
. . Name: NBTC -Technical Service Division
Address: C.R. 69220, Plot No. I , Block No. 5, Shuaiba Industrial Area
Calibration Method
The calibration was performed according to in-house method IC-F-CM-01 which is based on the method
recommended in IS0 7500-1 using standard equipment traceable to SI units through National or International
Standard.
Remarks
1. The attached results were obtained during the time of calibration and refer only to the particular
instrument submitted.
2. Should the instrument be modified or damage in any way, or develop inconsistent readings, the
results may not be valid and the unit will require recalibration.
3. This calibration certificate is issued in ac of ISOIIEC 17025 : 2017
standard.
4. Place of calibration: Customer's Plant.
CALIBRATION CERTIFICATE
Job Order No.: 21-3-23 Certificate No.: F/013/21 Issued Date: 25Jan-21
Calibration Results
Uncertainty of Measurement
The reoorted exoanded uncertaintv of measurement is stated as the standard uncertaintv of
measurement m'ultiplied by the co;erage factor k = 2, which for a normal distribution
corresponds to a coverage probability of approximately 95 %. The standard uncertainty of
measurement has been determined in accordance with A2LA
I .
if
Calibratedby
Eng. Ahmed Hany
Calibration Engineer
This certificate shaN not be reproduced except in full, without the written approval of the laboratory.
-- -
8-1 t \ .M :9.w
Organhatlonal +fll-lr.vr
Member +?to TtV\.VA- r ,j$
2475 2320 ?fY&W.
?tVbm-
?tV\lbT.
. ( t v l l ~ T l:yhl3
TESTING CERT#2487.01 & 2487.02
CALIBRATION CERT# 2487.03
hfO@lnco-lab.oom www.lnco-lab.com