Professional Documents
Culture Documents
3. HAZARDS IDENTIFICATION
Inhalation Exposure
If breathed in, move person to area of fresh air. If breathing becomes difficult, consult a physician.
Dermal Exposure
In case of skin contact, remove contaminated clothing, wash affected area with soap and copious amount of water.
Oral Exposure
If swallowed, wash out mouth with water provided the person is conscious. Call a physician.
Eye Exposure
Rinse eye thoroughly with plenty of flowing water for at least 15 minutes. Ensure adequate flushing by separating the
eyelids with fingers. Consult a physician.
________________________________________________________________________________________________________________
Veredus Laboratories Pte Ltd Page 1 of 4
Veredus Laboratories Private Limited
83 Science Park Drive, #04-02 The Curie
Singapore Science Park 1, Singapore 118258
Tel: +65 6496-8600, Fax: +65 6779-2680
Website: www.vereduslabs.com
Email: info@vereduslabs.com
5. FIRE-FIGHTING MEASURES
Special Risks
Specific Hazard(s): Emits toxic fumes under fire conditions.
Handling
Avoid contact with skin and eyes. Avoid inhalation of vapour or mist. Normal measures for preventive fire protection.
Storage
Keep container tightly closed. Store in 15°C to 30°C.
Respiratory Protection
Where risk assessment shows air-purifying respirators are appropriate, use a full-face respirator with multi-
purpose combination (US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering
controls. If the respirator is the sole means of protection, use a full-face supplied air respirator. Use
respirators and components tested and approved under appropriate government standards such as NIOSH
(US) or CEN (EU).
Hand Protection
The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the
standard EN 374 derived from it. Handle with protective gloves.
Eye Protection
Chemical safety goggles or Safety glasses.
Engineering Controls
Safety shower and eye bath. Mechanical exhaust required.
________________________________________________________________________________________________________________
Veredus Laboratories Pte Ltd Page 2 of 4
Veredus Laboratories Private Limited
83 Science Park Drive, #04-02 The Curie
Singapore Science Park 1, Singapore 118258
Tel: +65 6496-8600, Fax: +65 6779-2680
Website: www.vereduslabs.com
Email: info@vereduslabs.com
Appearance
Form Liquid
Colour Colourless
Odour Odourless
Safety Data
pH Not Determined
Melting point 0°C
Boiling point 100°C
Flash point Not Determined
Ignition temperature Not Determined
Lower explosion limit Not Determined
Upper explosion limit Not Determined
Density Not Determined
Water solubility Soluble in water
Storage Stability
Stable : Stable under normal conditions.
Materials to avoid : Strong oxidizing and reducing agents. Strong Acids. Potassium. Isocyanates. Ammonia. Bases.
Hazardous Polymerization
Will not occur.
Acute Toxicity
No acute toxicities known.
Sensitization
No sensitizing effects known.
Chronic Exposure
No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or
confirmed human carcinogen by IARC (International Agency for Research on Cancer).
To the best of our knowledge, the chemical, physical and toxicological properties have not been thoroughly
investigated.
________________________________________________________________________________________________________________
Veredus Laboratories Pte Ltd Page 3 of 4
Veredus Laboratories Private Limited
83 Science Park Drive, #04-02 The Curie
Singapore Science Park 1, Singapore 118258
Tel: +65 6496-8600, Fax: +65 6779-2680
Website: www.vereduslabs.com
Email: info@vereduslabs.com
Substance Disposal
Contact a licensed professional waste disposal service to dispose of this material. Dissolve or mix the material with a
combustible solvent and burn in a chemical incinerator equipped with an afterburner and scrubber. Observe all
federal, state and local environmental regulations.
Disclaimer: For R&D use only. Strictly not for drug or household uses.
The above information is believed to be accurate to the best of our knowledge and shall be used strictly as a guide
only. This shall not constitute a guarantee for any specific product features and shall not establish a legally valid
contractual relationship. All materials and mixtures may present unknown hazards and should be used with caution.
Veredus Laboratories Pte Ltd shall not be held liable for any damages or losses resulting from the handling or from
contact with the above product.
See reverse side of invoice or packing slip for additional terms and conditions of sale.
Copyright 2015 Veredus Laboratories Pte Ltd Licence granted to make unlimited paper copies for internal use only.
________________________________________________________________________________________________________________
Veredus Laboratories Pte Ltd Page 4 of 4