Professional Documents
Culture Documents
Hi,
I would like to seek help to you masters, i am doing a simulation using a submersible pump (ground water source)
i am confused on the elevation to be used.
in example. i have a subpump setting of 40m and the pumping waterlevel is 36m.
Renald.
Regards,
https://communities.bentley.com/products/hydraulics___hydrology/f/haestad-hydraulics-and-hydrology-forum/109912/submersible-pump-simulation-for… 1/3
11/02/2021 Submersible Pump Simulation for WaterGEMS - OpenFlows | Hydraulics and Hydrology Forum - OpenFlows | Hydraulics and Hydrology…
Sushma Choure
Offline Renald Cuevas Tue, Aug 18 2015 2:27 AM in reply to Sushma Choure
the pump is at 64m below the ground level and the PWL is at approximately 48m. how can i put
this into waterGEMS..
the last time i did was using only reservoir. but it is unlimited source of water where in i cant
relay on that result because we are adjusting flow rate to avoid break suction.
Offline Sushma Choure Tue, Aug 18 2015 6:39 AM in reply to Renald Cuevas
https://communities.bentley.com/products/hydraulics___hydrology/f/haestad-hydraulics-and-hydrology-forum/109912/submersible-pump-simulation-for… 2/3
11/02/2021 Submersible Pump Simulation for WaterGEMS - OpenFlows | Hydraulics and Hydrology Forum - OpenFlows | Hydraulics and Hydrology…
http://communities.bentley.com/products/hydraulics___hydrology/f/5925/t/58624
Regards,
Sushma Choure
Online Jesse Dringoli Tue, Aug 18 2015 8:41 AM in reply to Renald Cuevas
There is also a section in the Help called "Modeling a pumped groundwater well".
Drawdown can be accounted for in an adjusted pump curve and the reservoir elevation
would be the static groundwater elevation. The pump elevation will only effect the
calculated pressure at the pump, so you would set it to the elevation where you want to
measure pressure from.
Regards,
Jesse Dringoli
Technical Support Manager, OpenFlows Products
Bentley Communities Site Administrator
Bentley Systems, Inc.
https://communities.bentley.com/products/hydraulics___hydrology/f/haestad-hydraulics-and-hydrology-forum/109912/submersible-pump-simulation-for… 3/3