USE-Bus topology is a topology USE- A star topology is used to
where each device is connected to reduce the impact of a transmission a single cable which is known as line failure by independently the backbone. connecting each host to the hub.
ERROR RATE- In bus topology the
failure of the network cable will ERROR RATE- Failure in the cause the whole network to fail. central node affects the entire network but failure in one device does not affect the entire network. COMPLICATION IN NETWORK SETUP- This topology is easy to configure. COMPLICATION IN NETWORK FINDING A FAULT- In bus SETUP- The topology is less topology all the nodes are connected difficult to configure. to the backbone cable. The signal FINDING A FAULT- It depends on travels through the entire length of the host. It is easier to repair the the backbone and is received by the problematic host. However, if the node for which it is intended. nodes fail, then each node has to be Hence, fault diagnosis is difficult. searched. NETWORK FAILURE-In bus topology if the cable breaks at any NETWORK FAILURE- If host point, the computers on each side will fails, and then the network will also lose its termination. fail. If a node fails, then the network can still run.