Professional Documents
Culture Documents
XXXX
MMT-
2b) Tuck adhesive tab. Make sure that sensor’s CAUTION: Do not detach pedestal
adhesive tab is tucked under sensor connector from serter in mid-air as this may
and snaps. damage the sensor.
3) Load sensor into serter. Grip NOTE: Failing to hold serter securely flat against
serter exactly as shown with body may allow serter to spring back after
thumb on thumb print on pressing buttons and result in improper insertion
serter. Do not hold the side of sensor.
buttons. Push serter down
onto pedestal until base of
5b) Insert sensor. Press and
serter sits flat on table.
release bump on both
buttons at same time.
1
MINIMED® 670G SYSTEM | ONE-PRESS SERTER WITH GUARDIAN SENSOR 3
QUICK REFERENCE GUIDE
6) Remove needle housing. Gently hold base of 8b) Straighten adhesive tab.
sensor against skin with one hand. With other Straighten adhesive tab so
hand, hold needle housing at top and slowly pull it lies flat against your skin,
it straight away from sensor. Dispose of needle but do not remove adhesive
housing in sharps container. liner yet.
3
MINIMED® 670G SYSTEM | ONE-PRESS SERTER WITH GUARDIAN SENSOR 3
QUICK REFERENCE GUIDE
CALIBRATING
1) Select Snooze.
3) Once calibration BG is
entered, this screen will
display. You will begin
receiving sensor glucose
readings in 10 minutes.