Professional Documents
Culture Documents
Cad 2 Prelim Exercise 3 Wedge
Cad 2 Prelim Exercise 3 Wedge
Modeling toolbar :
The direction of the taper is always in the positive X-axis direction of the UCS.
Entering a positive value draws the height along the positive Z axis of the current UCS. Entering a
negative value draws the height along the negative Z axis.
The following prompts are displayed.
First corner
Other corner
Sets the opposite corner of the wedge base, located on the X,Y plane.
Center
Cube
Creates a wedge with sides of equal length.
Length
Creates a wedge with length, width, and height values you specify. The length corresponds to
the X axis, the width to the Y axis, and the height to the Z axis. If you pick a point to specify the
length, you also specify the rotation in the XY plane.
Height
Sets the height of the wedge. Enter a positive value to draw the height along the positive Z axis of
the current UCS. Enter a negative value to draw the height along the negative Z axis
2Point (height)
Defines the height of the wedge by specifying the distance between two points