Professional Documents
Culture Documents
WS05119 Band Saw Circle Jig
WS05119 Band Saw Circle Jig
Band Saw
Circle Jig
BLOCKS. You can clamp the jig to your band First, Blocks
saw’s table, or hold it in place with turn but- Second, glue
clamp jig to
#/8"-Dia.
band saw table through hole
tons. To attach turn buttons, cut two blocks and clamp
block to
so backboard centered on
is touching
11/2" wide and slightly less in thickness than bottom of base right edge
3" counterbore
tight against
the saw table. Then, glue the blocks to the left edge of table
of table
1!/2"
bottom of the base, tight against the left end
5 6
#/8" Carriage bolt.
of the table, see Fig. 3. Length may vary
TURN BUTTONS. To mount the jig to the table, 1"-Dia. counterbore,
#/8" deep
drill two counterbored holes for carriage CROSS
SECTION
bolts, see Fig. 4. Then make two turn but- Block Table
Block
tons to fit onto the bolts and use wing nuts
or knobs to tighten them down, see Fig. 5. Turn button
NOTE: Block is
ALIGNMENT. To align the jig for use, clamp it slightly thinner Swing
than band saw Turn button Wing nut turn button
down so the pivot nail aligns with the front of table thickness
or knob, to secure
and washer jig to table
the saw blade’s teeth.
1 WoodsmithPlans.com WS05119 ©2019 Cruz Bay Publishing, Inc. an Active Interest Media Company. All Rights Reserved.