You are on page 1of 2

Description

A Full adder can be realized using


Which Logic Gate is a basic comparator ?
A Multiplexer is also known as
Conversion of Binary to Octal decoder is constructed with
Full Adder Have---------Inputs And--------Outputs
 The simplified expression of Half Adder carry is
A Multiplexer with four select bits is a
A Logic Circuit that accepts several data inputs and allows only one of them at a time to get through to the output is called
A BCD to decimal decoder is a------ line decoder
Which adder plays a crucial role in eliminating the problem associated with the inter-stage carry delay?
A decoder converts n inputs to __________ outputs.
Decoder is constructed from ________________
A encoder converts ___ inputs to __________ outputs.
A digital multiplexer is a combinational circuit that selects___________
In a multiplexer, the selection of a particular input line is controlled by ___________
If the number of n selected input lines is equal to 2^m then it requires _____ select lines.
How many select lines would be required for an 8-line-to-1-line multiplexer?
In SR flipflop , if S=0,R=0; the state is
How many NOT gates are required for the construction of a 4-to-1 multiplexer?
Which flip-flop plays a vital role by functioning as the basic building block of a ripple counter?
Which among the following sequential logic circuits are adopted for the designing of a sequence generator?
In a sequence detector, if the required bit is at its input while checking the sequence bit by bit, the detector moves to _______
Which among the following is not a mode of Flip Flop representation?
Why is the extent of propagation delay in synchronous counter much lesser than that of asynchronous counter?
If the output of two-bit asynchronous binary up counter using T flip flops is '00' at reset condition, then what output will be ge
For a ring counter, the number of output states are always equal to ______
In delay flip-flop, _______ after the propagation delay.
Which type of triggering phenomenon is exhibited by Counters?
Which sequential circuits are applicable for counting pulses?
If the number of states in a counter are 2n, then the value of 'n' is ________
The output of Up counters goes on increasing due to _________
When the mode control pin is connected to ground, Universal Shift Register acts as ____
Which type of triggering is shown by the D flip flops in buffer registers for the temporary storage of digital words?
Which is the prohibited state/ condition in S-R latch and needs to be avoided due to unpredictable nature of output?
A basic S-R flip-flop can be constructed by cross-coupling which basic logic gates?
If both inputs of an S-R NAND latch are LOW, what will happen to the output?
How is a J-K flip-flop made to toggle?
A J-K flip-flop is in a "no change" condition when ________.
The characteristic equation of J-K flip-flop is ______________
In a J-K flip-flop, if J=K the resulting flip-flop is referred to as _____________
The only difference between a combinational circuit and a flip-flop is that _____________
Both the J-K & the T flip-flop are derived from the basic _____________
In J-K flip flop, if J=1 , K=1 & Qn=0 then Qn+1=__________
The characteristic equation of T flip-flop is ______________
The characteristic equation of SR flip-flop is ______________
How many flip-flops are required to make a MOD-32 binary counter?
How many different states does a 3-bit asynchronous counter have?
A 4-bit up/down counter is in the DOWN mode and in the 1100 state. To what state does the counter go on the next clock pul
The difference between a PLA and a PAL is:
In a 6-bit Johnson counter sequence there are a total of how many states, or bit patterns?
A ROM which can be programmed is called a
A combinational PLD with a fixed AND array and a programmable OR array is called a
A combinational PLD with a programmableAND array and a programmable OR array is called a
A combinational PLD with a programmable AND array and a fixed OR array is called a
A table specifying the fuse map of a PLA is called a
PLA consists of
A 32x10 ROM contains a decoder of size
PLA is
Static 1 hazard is___________ type of hazard
A 8x4 ROM contains a decoder of size______

You might also like