Professional Documents
Culture Documents
B Range Flat Anchorages FREYSSINET PDF
B Range Flat Anchorages FREYSSINET PDF
Freyssinet - 1 bis rue du Petit-Clamart - 78140 Vélizy-Villacoublay - Tel : +33 (0)1 46 01 84 84 - Fax : +33 (0)1 46 01 85 85 - www.freyssinet.com
B RANGE FLAT ANCHORageS
INSTALLATION performances
The post-tensioning equipment is generally Approval static tests according to BS 4447 have been carried out on the anchorages
installed as follows: of the B range.
• Ducts and trumplates installation
They can be used with all classes of standard or super strands (T13, T13S, T15,
• Placement of tendons and anchorages T15S), in concrete structures. B range anchorages can be used on slabs with a
minimal thickness of 180 mm. The minimal concrete compressive strength at
The threading of the strands is carried out before
stressing shall be the following depending on the strand type :
concreting. When the concrete reaches a sufficient
resistance, the recess formwork is removed to allow
the assembly of the anchorage blocks and wedges. Strand type Minimal cylinder concrete Minimal cube concrete
compressive strength compressive strength
• Tensioning T13 S 20 MPa 25 MPa
The stressing of the tendons is carried out strand T15 21 MPa 26 MPa
by strand using a monostrand jack with a specific T15 S 23 MPa 28 MPa
adaptation allowing the correct alignment of the
jack and a mechanical wedges adjustment.
Where the tensioning of anchorages is not possible Bursting reinforcement
from slab edge a specific adaptation with a curved
The recommended bursting reinforcement is described in the sketch below.
nose shall be used.
All rights reserved by Freyssinet. The product names are Freyssinet Trademarks. The Information contained in this document is subject to change. Although best efforts
were made to ensure maximun accuracy of this information, Freyssinet may not be held liable for this accuracy in any respect.