You are on page 1of 4

GSLP Strength Bias

www.barbellmedicine.com /gslp-strength-bias/

Jordan Feigenbaum

GSLP Strength Bias

By Jordan Feigenbaum MS, CSCS, HFS, USAW Club Coach

Greyskull Linear Progression (GSLP) by Johnny Pain is a great novice to intermediate program. It is geared
somewhere between a pure strength and pure hypertrophy program as it involves both higher rep sets and isolation
movements, as will as including heavy sets across of the big exercises. You can purchase his e-book on the
technique off his website. What I’ve done here is modified it for a strength bias, that is for someone who aims to get
much stronger and gain muscle, but with an emphasis on strength. Here is how it goes:

Setup:

The setup for this program is very similar to setting up the Texas Method and original GSLP. We’ll base all your
working sets based on your previous 5RM’s and go from there. This is a 3-day per week setup where you train on
non-consecutive days. It also follows linear progression in that weight is added to the bar in a weekly fashion, thus it
is an intermediate program. It can also be adapted to an advanced athlete, as I’ll cover in the modifications section.
Based on the following 5RM’s:

Squat-205 x 5

Bench-225x 5

Deadlift-245 x 5

Press- 115 x 5

Day 1- Volume Day for Pressing variant and Squats

A) Press-5-5-5+ @105lbs

B) Bench Press-5-5-5+ @ Day 2’s weight + 2.5lbs-5lbs

A) Body weight Chins x max reps x 3 sets

B) Curls x 12-15 x 2 sets

C) Squats x 5-5-5+ @ 185lbs

*5+ means go for maximum reps. Week 1’s 3rd set of 5 should be somewhere north of 10 reps, choose the weight
appropriately.

1/4
**Alternate A/B based on week. On a “A” week the lifter will press on Days 1 and 3, while they will bench press on
Day 2. On a “B” week the lifter will bench press on Days 1 and 3, while pressing on day 2. The same alternating
schedule of curls and weighted chins/body weight chins holds true here.

Day 2- Volume Day for 2nd Pressing Variant and Deadlifts

A) Bench Press x 5-5-5+ @205lbs

B) Press-5-5-5+ @ Day 1 from week 1’s weight + 2.5-5lbs

C) Power Clean (as warm up for deadlift) x 3 x 3, x 2 x 1, x 1 until a miss

D) Deadlift x 5+ @ 245

Day 3-Intensity Day for Press Variant and Squat Variant

A) Press x 4-6 @ 120lbs, 12-15 @95lbs

B) Bench Press -4-6 @ 235lbs, 12-15 @ 185lbs

A) Weighted Chins x 6-8 reps x 2 sets

B) Curls x 12-15 x 2 sets

C) Squats x 4-6 @ 205, x 12-20 @ 170lbs

Accessory Work:

Pick two non-overlapping (i.e. one upper and one lower body) accessory exercises MAX on each training day.
These are to be done after the main work has been done and the lifter should keep in mind that there is training to
be done in 48 hours, so these shouldn’t wreck the lifter.

Lower Body:

Good Mornings x 6-8 x 3 sets

Paused Good Mornings x 5 x 2 sets

RDL’s x 8-15 x 3 sets

SLDL x 5-15 x 1 set

Deficit pulls x 5-15 x 1 set

Power Shrugs x 5-15 x 2 sets

GHR/GHD Situps x 10-20 x 3 sets

Upper Body:
2/4
Lying Triceps Extensions x 8-15 x 3 sets

Chin-Up Ladders

Dips (bodyweight) x 12-15 x 3 sets

Dips (weighted) x 6-8 x 2 sets

JM Press x 5-10 x 2-3 sets

V-Grip Pull Down x 12-15 x 2-3 sets

Plug-Ins:

Plug-ins can be done daily with the caveat that there is one day of complete rest per week, usually on Sunday.
These methods are used to increase muscular size, strength, and capacity while exposing the lifter to increased
volume of very submaximal movements over the course of weeks, months, and years. Take for instance the
venerable push-up. While the push-up is a great movement to build the chest and pressing strength or capacity, it
requires obscene amounts of volume to be effective for anyone who can actually knock out 40+ legit push-ups. So
what we’ll do is multiple submaximal sets spread throughout the day of say 15 reps x 4 sets for a total of 60 pushups
per day. This gives us 240 pushups a week (one day of rest, remember?) and 960 pushups a month. Do you think
this will increase or decrease your capacity to push against something? Do you also think this might help develop
the musculature of the chest, shoulders, and triceps? The same holds true when pairing the submaximal (not to
failure) sets of pushups with multiple sets of chin-ups to failure or chin-ladders on a daily basis.

Here are some good ideas to “plug-in”:

Frequency method Push-ups (must be accompanied by FM chins)

Frequency method Chin-ups

Frequency method band pull-aparts

Frequency method triceps extensions

Neck Work with neck harness

Don’t try and do all of these at once. I find that most get good mileage out of doing the push-ups and chin-ups at
SUB MAXIMAL sets, that is, there is never a failed rep. If you don’t have access to a chinning bar during the day
just do chin ladders at the end of each workout to accompany the pushups.

Progression:

The most important aspect of any program is progression. Add weight weekly to the lifts, 2-5lbs on upper body and
5-10lbs on lower body, and if you only get the requisite reps (5-5-5) on volume day, or on intensity day (4 and 12)
keep the weight the same for the next week/session until you crush the rep range into submission.

Odds are this program can be run a long time. Stalling will either occur from too aggressive of weight increases too
frequently or from a lack of recovery due to incorporating too many other things, given that form is correct.

Modifications:

As the lifter progresses, a DE setup can be employed on the squat and pressing volume days. The squats will use
10 sets of 2 on a minute clock (getting under the bar at the 30s mark) with 50-60% of the lifters raw 1RM. This
percentage is an estimate and the reps must be explosive. On bench and press the reps will be 8 sets of 3 on a
3/4
minute clock with the same loading protocol. Keep Wednesday’s volume the same for upper body as using straight
weight will still be useful, especially the money-maker 3rd set. Speed pulls can be subbed in for traditional deadlifts
as well when deadlifts creep up towards the mid 400’s and above. At that point pulling 1-3 heavy singles that are
progressed weekly after Friday’s squat workout will be useful.

About 4-6 weeks out from the meet switch the setup for 2x a week bench pressing with Wednesday being the press
day, Also, switch the intensity day to paused singles (1-1-1-1-1) for bench press and five singles for squats before
the back-off sets.

Failure:

If/when failure occurs you are at a crossroads. You can switch the movement for a closely related one that you
believe carries over (i.e. bench press subbed out for incline bench or press switched for seated press or dumbbell
press) or switch the rep range (5-5-5+ to 3-3-3-3-3+). I find that taking a 3-4 week break on the movements is useful
to get things moving again on the main lifts. Here are some useful substitutions:

Stalled Lift>>>>>>>>>>>>>>>>>>>>>>Subbed Lift

Bench Press Incline Bench Press

Press Standing DB Press

Deadlift Deficit/Snatch Grip Deadlift

Back Squat Box Squat/ Front Squat

Power Clean Hang Clean/ Power Snatch

Weighted Chin Ups Weighted Pull Ups

Overall, this program should get you figuring out what works for you as far as progression, volume, intensity, and
frequency goes when planning your workouts. If you have any questions post them to the comments!

-thefitcoach

4/4

You might also like