Professional Documents
Culture Documents
CD RECEIVER
5
2013
KD-R440J, KD-R440JW, KD-R441E, KD-R441EN, KD-R441EU,
SERVICE MANUAL
MA538<Rev.003>
Mounting sleeve Hard case assy * DC cord * DC cord * Remocon unit (RM-RK52) *
(GE20316-001A) (GE32320-001A) (QAM1344-00x) (QAM13xx-001) (RM-RK52xx)
(No.MA538<Rev.003>)2/18
SPECIFICATION
For Asia
Audio amplifier
Maximum Power Output 50 W per channel
Continuous Power Output (RMS) 20 W per channel into 4Ω, 40 Hz to 20 000 Hz at less than 1% total harmonic distortion
Load Impedance 4 Ω (4 Ω to 8 Ω allowance)
Frequency Response 40 Hz to 20 000 Hz
Signal-to-Noise Ratio 70 dB
Line-Out or Subwoofer-Out Level/Impedance 4.8 V/10 kΩ load (full scale)
Output Impedance ≤ 600Ω
Tuner
FM Frequency Range 87.5 MHz to 108.0 MHz (50 kHz step)
Usable Sensitivity 9.3 dBf (0.8 µV/75Ω)
50 dB Quieting Sensitivity 16.3 dBf (1.8 µV/75Ω)
Alternate Channel Selectivity 65 dB (at 400 kHz)
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation 40 dB
AM Frequency Range MW : 531 kHz to 1 611 kHz (9 kHz step)
SW1 : 2 940 kHz to 7 735 kHz (5 kHz step)
SW2 : 9 500 kHz to 10 135 kHz/11 580 kHz to 18 135 kHz (5 kHz step)
Sensitivity/Selectivity 20 µV/40 dB
CD player
Signal Detection System Non-contact optical pickup (semiconductor laser)
Number of Channels 2 channels (stereo)
Frequency Response 5 Hz to 20 000 Hz
Signal-to-Noise Ratio 98 dB
Wow and Flutter Below measurable limit
USB
USB Standard USB 1.1, USB 2.0
Data Transfer Rate (Full Speed) Max. 12 Mbps
Compatible Devices Mass storage class
Compatible File Systems FAT 32/16/12
Playable Audio Formats MP3/WMA
Maximum Supply Current DC 5 V 1A
General
Power Requirement (Operating Voltage) DC 14.4 V (11 V to 16 V allowance)
Grounding System Negative ground
Allowable Operating Temperature 0°C to +40°C
Dimensions Installation Size (approx.) 182 mm × 53 mm × 159 mm
(W × H × D) Panel Size (approx.) 188 mm × 59 mm × 13 mm
Weight (excluding accessories) 1.2 kg
• Subject to change without notice.
(No.MA538<Rev.003>)3/18
SPECIFICATION
For Europe
Audio amplifier
Power Output 50 W per channel
Continuous Power Output (RMS) 20 W per channel into 4Ω, 40 Hz to 20 000 Hz at less than 1% total harmonic distortion
Load Impedance 4 Ω (4 Ω to 8 Ω allowance)
Frequency Response 40 Hz to 20 000 Hz
Signal-to-Noise Ratio 70 dB
Line-Out or Subwoofer-Out Level/Impedance For KD-R547/KD-R541/KD-R449 : 2.5 V/10 kΩ load (full scale)
Output Impedance ≤ 600Ω
Tuner
FM Frequency Range For KD-R541/KD-R443 /KD-R442/KD-R441/KD-R449 : FM: 87.5 MHz to 108.0 MHz
For KD-R547/KD-R449 /KD-R447 : FM: 87.5 MHz to 108.0 MHz / FM-LO: 65.0 MHz to
74.0 MHz
Usable Sensitivity 9.3 dBf (0.8 µV/75Ω)
50 dB Quieting Sensitivity 16.3 dBf (1.8 µV/75Ω)
Alternate Channel Selectivity 65 dB (at 400 kHz)
Frequency Response 40 Hz to 15 000 Hz
Stereo Separation 40 dB
AM Frequency Range MW : 531 kHz to 1 611 kHz
LW : 153 kHz to 279 kHz
Sensitivity/Selectivity MW : 20 µV/40 dB
LW : 50 µV/-
CD player
Signal Detection System Non-contact optical pickup (semiconductor laser)
Number of Channels 2 channels (stereo)
Frequency Response 5 Hz to 20 000 Hz
Signal-to-Noise Ratio 98 dB
Wow and Flutter Below measurable limit
USB
USB Standard USB 1.1, USB 2.0
Data Transfer Rate (Full Speed) Max. 12 Mbps
Compatible Devices Mass storage class
Compatible File Systems FAT 32/16/12
Playable Audio Formats MP3/WMA
Maximum Supply Current DC 5 V 1A
General
Power Requirement (Operating Voltage) DC 14.4 V (11 V to 16 V allowance)
Grounding System Negative ground
Allowable Operating Temperature 0°C to +40°C
Dimensions Installation Size (approx.) 182 mm × 53 mm × 159 mm
(W × H × D) Panel Size (approx.) 188 mm × 59 mm × 13 mm
Weight (excluding accessories) 1.2 kg
• Subject to change without notice.
(No.MA538<Rev.003>)4/18
SECTION 1
PRECAUTION
1.1 Safety Precautions
(1) This design of this product contains special hardware and voltmeter.
many circuits and components specially for safety purpos- Move the resistor connection to each exposed metal
es. For continued protection, no changes should be made part, particularly any exposed metal part having a return
to the original design unless authorized in writing by the path to the chassis, and measure the AC voltage across
manufacturer. Replacement parts must be identical to the resistor. Now, reverse the plug in the AC outlet and
those used in the original circuits. Services should be per- repeat each measurement. Voltage measured any must
formed by qualified personnel only. not exceed 0.75 V AC (r.m.s.). This corresponds to 0.5
mA AC (r.m.s.).
(2) Alterations of the design or circuitry of the product should
AC VOLTMETER
not be made. Any design alterations of the product should (Having 1000
not be made. Any design alterations or additions will void ohms/volts,
the manufacturers warranty and will further relieve the or more sensitivity)
manufacture of responsibility for personal injury or property
damage resulting therefrom. 0.15 F AC TYPE
Place this
(3) Many electrical and mechanical parts in the products have probe on
special safety-related characteristics. These characteris- each exposed
tics are often not evident from visual inspection nor can the 1500 10W metal part.
protection afforded by them necessarily be obtained by us-
ing replacement components rated for higher voltage, watt- Good earth ground
age, etc. Replacement parts which have these special
safety characteristics are identified in the Parts List of Ser-
vice Manual. Electrical components having such features 1.2 Warning
are identified by shading on the schematics and by ( ) on (1) This equipment has been designed and manufactured to
the Parts List in the Service Manual. The use of a substitute meet international safety standards.
replacement which does not have the same safety charac- (2) It is the legal responsibility of the repairer to ensure that
teristics as the recommended replacement parts shown in these safety standards are maintained.
the Parts List of Service Manual may create shock, fire, or (3) Repairs must be made in accordance with the relevant
other hazards. safety standards.
(4) It is essential that safety critical components are replaced
(4) The leads in the products are routed and dressed with ties, by approved parts.
clamps, tubings, barriers and the like to be separated from (5) If mains voltage selector is provided, check setting for local
live parts, high temperature parts, moving parts and/or voltage.
sharp edges for the prevention of electric shock and fire
hazard. When service is required, the original lead routing
and dress should be observed, and it should be confirmed 1.3 Caution
that they have been returned to normal, after reassem- Burrs formed during molding may be left over on some parts
bling. of the chassis.
Therefore, pay attention to such burrs in the case of pre-
(5) Leakage shock hazard testing forming repair of this system.
After reassembling the product, always perform an isola-
tion check on the exposed metal parts of the product (an-
tenna terminals, knobs, metal cabinet, screw heads, 1.4 Critical parts for safety
headphone jack, control shafts, etc.) to be sure the product
is safe to operate without danger of electrical shock.Do not In regard with component parts appearing on the silk-screen
use a line isolation transformer during this check. printed side (parts side) of the PWB diagrams, the parts that are
• Plug the AC line cord directly into the AC outlet. Using a printed over with black such as the resistor ( ), diode ( )
"Leakage Current Tester", measure the leakage current and ICP ( ) or identified by the " " mark nearby are critical
from each exposed metal parts of the cabinet, particular- for safety. When replacing them, be sure to use the parts of the
ly any exposed metal part having a return path to the same type and rating as specified by the manufacturer.
chassis, to a known good earth ground. Any leakage cur- (This regulation dose not Except the J and C version)
rent must not exceed 0.5mA AC (r.m.s.).
• Alternate check method
Plug the AC line cord directly into the AC outlet. Use an
AC voltmeter having, 1,000Ω per volt or more sensitivity
in the following manner. Connect a 1,500Ω 10W resistor
paralleled by a 0.15µF AC-type capacitor between an ex-
posed metal part and a known good earth ground.
Measure the AC voltage across the resistor with the AC
(No.MA538<Rev.003>)5/18
1.5 Preventing static electricity
Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser
diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs.
1.5.1 Grounding to prevent damage by static electricity
Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as laser products.
Be careful to use proper grounding in the area where repairs are being performed.
(1) Ground the workbench
Ground the workbench by laying conductive material (such as a conductive sheet) or an iron plate over it before placing the
traverse unit (optical pickup) on it.
(2) Ground yourself
Use an anti-static wrist strap to release any static electricity built up in your body.
(caption)
Anti-static wrist strap
1M
Conductive material
(conductive sheet) or iron palate
(3) Handling the optical pickup
• In order to maintain quality during transport and before installation, both sides of the laser diode on the replacement optical
pickup are shorted. After replacement, return the shorted parts to their original condition.
(Refer to the text.)
• Do not use a tester to check the condition of the laser diode in the optical pickup. The tester's internal power source can easily
destroy the laser diode.
SOLDER
(No.MA538<Rev.003>)6/18
1.7 Important for laser products
1.CLASS 1 LASER PRODUCT 5.CAUTION : If safety switches malfunction, the laser is able
to function.
2.CAUTION :
(For U.S.A.) Visible and/or invisible class II laser radiation 6.CAUTION : Use of controls, adjustments or performance of
when open. Do not stare into beam. procedures other than those specified here in may result in
(Others) Visible and/or invisible class 1M laser radiation hazardous radiation exposure.
when open. Do not view directly with optical instruments.
(No.MA538<Rev.003>)7/18
SECTION 2
SPECIFIC SERVICE INSTRUCTIONS
2.1 Identifying the CD Mechanism
This unit is equipped with one of the two CD mechanism types below.
• FLM-HC3-1D
• FLM-HC5-1D
Before sending the mechanism for repair, please check the following and refer to the corresponding materials.
SPECIFICATION
MODEL NAME STAMP No.
FLM-HC3-1D H31
FLM-HC5-1D H51
(No.MA538<Rev.003>)8/18
SECTION 3
DISASSEMBLY
3.1 Main body (Used model: KD-R441E) (2) Remove the 2 screws B attaching both sides of the Top
3.1.1 Removing the Bottom chassis (See Fig.1) chassis. (See Fig.4)
(1) Disengage the 7 hooks a engaging the Bottom chassis.
(2) Slide the Bottom chassis backward to remove it.
B
Fig.4
(3) Remove the 2 screws C and 1 clamp attaching the Electric
a unit. (See Fig.5)
a Clamp
C
a
Fig.1
3.1.2 Removing the Front chassis (See Fig.2)
(1) Disengage the 4 hooks b engaging both sides of the Front
chassis.
Fig.5
(4) Disconnect the FFC wire connected to connector CN101 of
the CD mechanism. (See Fig.6)
b
Fig.2
3.1.3 Removing the Electric unit (See Fig.3, 4 and 5)
(1) Remove the 1 screw A attaching the Top chassis. (See Fig.3)
CN101
Fig.6
A
Fig.3
(No.MA538<Rev.003>)9/18
3.1.4 Removing the CD mechanism (See Fig.7) 3.2 CD mechanism assembly section
(1) Remove the 2 screws D attaching the CD mechanism. 3.2.1 Removing the Mecha control board
(1) Solder the short land on the pickup. (See Fig. 1)
D
SOLDER
Fig.1
(2) Remove the 8 wires from the Mecha control board. (See
Fig.2)
Fig.7
3.1.5 Removing the Switch unit (See Fig.8)
(1) Remove the Volume knob.
(2) Remove the 4 screws E attaching the Rear cover.
(3) Disengage the 12 hooks c engaging the Rear cover.
c
c c BLACK
RED
WHITE
E c E YELLOW
Fig.8 ORANGE
ORANGE
WHITE
YELLOW
Fig.2
(3) Disconnect the flexible wire from the pickup connected to
the connector CN102 on the Mecha control board. (See
Fig.3)
(4) Remove the 2 screws A attaching the Mecha control board.
(See Fig.3)
CN102
Fig.3
(No.MA538<Rev.003>)10/18
3.2.2 Removing the Traverse mechanism (See Fig.4, 5) (2) Remove the shaft from the TM base. (See Fig.7)
(1) Remove the 5 springs from the traverse mechanism. (See (3) Disengage the hook a on the pickup from the TM base.
Fig.4) (See Fig.7)
shaft
Fig.4
(2) Remove the 3 screws B attaching the bottom frame as-
sembly. (See Fig.5)
(3) Remove the 3 dumpers from the bottom frame assembly.
(See Fig.5)
Fig.7
3.2.4 Removing the Spindle motor (See Fig.8. 9)
(1) Remove the HC CL. Spring from the HC CL. base and the
TM base, and then lift up the HC CL. base. (See Fig.8)
B
Fig.5
3.2.3 Removing the Pickup (See Fig.6, 7)
(1) Remove the 2 screws C attaching the feed bracket assem-
bly. (See Fig.6)
C C
HC CL. spring
[ SIDE VIEW ]
Fig.8
Fig.6
(No.MA538<Rev.003>)11/18
(2) Remove the HC CL. base from the holes on the TM base. 3.2.5 Removing the Loading motor
(See Fig.9) (1) Remove the roller arm assembly from the bottom frame as-
sembly. (See Fig.11)
Fig.9
(3) Remove the 2 screws D attaching the spindle motor. (See
Fig.10)
D
Fig.11
(2) Remove the 2 screws E attaching the loading motor as-
sembly, and then remove the loading motor assembly in
the direction of the arrow. (See Fig.12)
Fig.10
Fig.12
(No.MA538<Rev.003>)12/18
SECTION 4
ADJUSTMENT
4.1 Service Test mode
4.1.1 Default status immediately after the mode activation
Operating Key: [MENU] + [] (7sec) Press and hold.
4.1.2 How to release each Test mode
• Reset
• Acc off
• Power off
• Panel Detach
4.1.3 Mode content
Syscon shall display the following information after entering this mode. The operation shown below shall be workable.
Display content Detail
(No.MA538<Rev.003>)13/18
4.1.5 CD error information display mode
Operation Display content Detail
CD mecha error Mecha error history 1,2,3 (latest)
log display # = History No. (1,2,3)
XX : kind of errors, " -- " when there is
none.
00: No Error
04: TOC read Error
M E C H A E R # X X 05: Unknown CD
06: Heat Error
0A: Update Error
0D: Hold Error
15: Unknown Disc
99: Mecha Error
CD load error Load error switch 1,2
information display # = History No. (1,2)
L O A D E R # X X XX: numbers of errors, " -- " when there
is none
History No. 2 is un-used
CD eject error Eject error switch 1,2,3,4
information display # =History No. (1,2,3,4)
XX: numbers of errors, " -- "when there
Move is none
between History No.3 is un-used
E J E C T E R # X X History No.1: Eject before SW1 is on.
[DISP]
History No.2: Eject until SW1 and SW2
(Forward is on.
search) History No.3: Eject between SW2 on
item with and Eject end
CD time code error C N T L O S E CD-DA error count number information
[] / [] count information
display (count skip) CD-DA error count numbers
XX: numbers of errors and " -- " when
C D D A X X there is none
Can only be checked via debugger by
jap member
CD-ROM (compressed file) error count
numbers
XX: numbers of errors and " -- " when there
C D R O M X X is none
Can only be checked via debugger by jap
member
CD time code error CD time code error count information
count information C N T S T A Y (count not updated) mode display
display (no count CD-DA error count numbers
update) XX: numbers of errors and " -- " when
C D D A X X
there is none
CD-ROM (compressed file) error count
numbers
C D R O M X X XX: numbers of errors and " -- " when
there is none
CD error CD error information all clear Clear CD error information by pressing
[EQ] information clear for 2 seconds when it is displayed.
M E C H A E R 1 - -
[EQ] Mode release CD error information display mode release Back to default status, All lights on
(No.MA538<Rev.003>)14/18
4.2 Service Information Clear Mode
4.2.1 Default status immediately after the mode activation
* The receiver is connected with the DC power supply (with the power supply turned off).
Operating Key: [BACK] + [POWER] Press and hold + DC power supply turned ON
4.2.2 How to release each Test mode
• Reset
• Acc off
• Power off
• Panel Detach
4.2.3 Mode content
After entering this mode, Syscon shall clear the information stored for service and output the result to the display tube.
CD will be ejected upon process ended.
Preset Frequencies and Tagging (HD models) information shall be cleared.
Display content Detail
When normal end
D A T A C L R O K
When error end
D A T A C L R N G Display blinks with 250ms interval.
The following table shows the data that is cleared.
Information for data clearing Detail Storage area
CD mecha log display E2PROM
CD load error information display E2PROM
CD mecha information CD eject error information display E2PROM
CD time code error count information display (count skip) E2PROM
CD time code error count information display (no count update) E2PROM
CD EJECT number of times display E2PROM
Service information
Force Power OFF information display E2PROM
DC error 1 display (wrong connection & other detection information in detecting duration) E2PROM
DC error information
DC error 2 display (capacitor leakage detection number information) E2PROM
Tuner Area Setting E2PROM
Preset Frequency E2PROM
Preset information
Preset PI code E2PROM
Preset HD Station Name and Sub-Channel Number (HD models) E2PROM
SXM Preset Channel SID E2PROM
Sirius XM information SXM Lock SID E2PROM
(Sirius models) SXM Last Channel ID E2PROM
SXM Channel Lock Code E2PROM
Tagging information (HD models) Token data memory index E2PROM
(No.MA538<Rev.003>)15/18
4.3 DC error information mode
4.3.1 Default status immediately after the mode activation
* The receiver is connected with the DC power supply (with the power supply turned off).
Operating Key: [MENU] + [] Press and hold + DC power supply turned ON
4.3.2 How to release each Test mode
• Reset
• Acc off
• Power off
• Panel Detach
4.3.3 Mode content
Syscon shall display the following information after entering this mode. The operation shown below shall be workable.
Display content Detail
When DC error is detected (in case that one of capacitor leakage,
D C E R R
wrong connection or other detection is found).
When DC error is not detected (in case that none of capacitor leak-
D C O K
age, wrong connection or other detection is found).
4.3.4 Mode operation specification
means Press and hold
Operation Display content Detail
DC ERR1 When wrong connection & DC error in other de-
D C 1 E R R
display tection duration is detected.
[]
When wrong connection & DC error in other de-
D C 1 O K
tection duration is not detected.
DC ERR1 Clear detection information when wrong con-
[] clear D C 1 O K nection & DC error in other detection duration is
displayed.(Clear data flash)
DC ERR2 Display detecting number of times in capacitor
[] D C 2 4
display leakage detection duration (0 - 4)
DC ERR2 Clear number of times for detection information
[] clear D C 2 0 in capacitor leakage detection duration.(Clear
data flash)
(No.MA538<Rev.003>)16/18
4.4 DC offset error description 4.4.5 Manipulate after detect DC offset
4.4.1 DC offset detection circuit design • If detected error 10 consecutive times, and 10th error occurred
• Purpose: in "Mis-connect detection period", judge as "Mis-connect".
To prevent breakdown, burning and emitting smoke from cus- • If detected error 10 consecutive times, and 10th error occurred
tomer's car speaker when occur DC offset between speaker in "Capacitor leak detection period", judge as "Capacitor leak ".
output "+" and "-". • If detected error 10 consecutive times, and 10th error occurred
• Target: in "Other detection period" and detected another 10 errors con-
Detect DC offset, then stop the Power Amp operation and shift secutively, then judge as "Other".
to specified condition. • If judge as "Mis-connect".
- turn off speaker output.
4.4.2 Possible causes of DC offset at speaker output lines - display "MIS WIRING" → "CHK WIRING" → "THEN RESET"
(1) Mis-connection for speaker output for example touch to car → "UNIT".
body or battery line. - key access disable except button of Eject, Reset and service
(2) Current leak of coupling capacitor for Power IC input. mode
(3) Current leak of Ac-GND capacitor for Power IC Ac-GND. - record error in EEPROM "DC1 ERR"
(4) Capacitor shorted of above parts due to foreign object. - Set is able to be recovered by Reset button.
E-Vol • If judge as "Capacitor leak ".
Audio Pwr Amp
C-in - turn off speaker output.
In 1
C-in
- display "WARNING" → "CHK WIRING" → "THEN RESET"
In 2 → "UNIT".
C-in
In 3 - key access disable except button of Eject, Reset and service
C-in
In 4 mode
- record error in EEPROM "DC2 #" (# means counter number)
C-ac1 C-ac2
- Set can be recovered by pressing the Reset button before
AcGnd
the capacitor leak error counter reach "DC2 4".
C-tc After that, only clear the counter back to "0" can recover the
Sw5V
Win_TC
set.
R2 • If judge as "Other" (manipulation same as mis-connect)
R1 Offset Detect
Win_In Out
R3 C3
DC Error
R4
Micon
ADC In
SECTION 5
TROUBLESHOOTING
4.4.3 Type of checking
4.4.3.1 To detect DC offset Error 5.1 How to cancel DC offset error
• Mis-connection
Check to be sure the terminals of the speaker leads are covered
- Short any one speaker out line to GND or Vcc
with insulating tape properly, then reset the unit.
• Capacitor leak If an error message does not disappear even after a reset, there
- Parallel 330kΩ to either any one of coupling cap or Ac-GND
is a need for internal repair.
cap (to simulate current leakage of capacitor)
- Shorted either any one of coupling cap or Ac-GND cap. 5.2 How to clear DC offset error recorded in EEPROM
4.4.4 Detection Timing chart DC Error Information Mode is started.
2.0sec or more 1.5sec or more 50ms
[MENU] + [] Press and hold + DC power supply turned ON
or more DC1 ERR → [] Press and hold.→ DC1 OK
0.7sec or more
0.8sec 1.0sec DC2 1-4 → [] Press and hold.→ DC2 0
PWIC_STBY
PWIC_MUTE
AUD_MUTE
(No.MA538<Rev.003>)17/18
JVC KENWOOD Corporation
Car Electronics Business Group 2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525, Japan
(No.MA538<Rev.003>)
Printed in Japan
VSE
SCHEMATIC DIAGRAMS
CD RECEIVER
KD-R440J KD-R440JW KD-R441E
KD-R441EN KD-R441EU KD-R441EY
KD-R442E KD-R442EN KD-R442EY
KD-R443E KD-R443EN KD-R443EY
KD-R444UI KD-R445U KD-R445UN
KD-R446EU KD-R446U KD-R446UN
KD-R446UP KD-R446UT KD-R447EE
KD-R449E KD-R449EE KD-R449UR
KD-R540J KD-R541E KD-R541EN
KD-R541EY KD-R547EE
(No.MA538<Rev.003>)1/19
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS
z Due to the improvement in performance, some part numbers shown in the circuit diagrams
may not agree with those indicated in the Parts List.
z The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for
reference only.
z Since the circuit diagrams are standard ones, the circuits and circuit constants may be
subject to change for improvement without any notice.
■ PRECAUTIONS ON SERVICE
Certain parts of the power circuits and the GNDs differ according to the models. Care must be
taken for the following points as the differences are indicated separately in the LIVE GND ( ) and
the ISOLATED (NEUTRAL) GND ( ).
1. Do not touch the LIVE GND, or do not touch the LIVE GND and the ISOLATED (NEUTRAL)
GND at the same time. It may cause an electric shock.
Before pulling out the chassis or other parts, make sure to pull out the power cord from the
wall outlet first.
2. Do not short circuit between the LIVE GND and ISOLATED (NEUTRAL) GND, or never
measure the LIVE GND and ISOLATED (NEUTRAL) GND at the same time using measuring
instruments (oscilloscope, etc.). It may blow fuses or damage other parts.
(No.MA538<Rev.003>)2/19
BLOCK DIAGRAM
FM/AM
ANT J321(1PRE)
IC1
MUTE MUTE
IC501
CIRCUITRY
*Remark
DRV_Mute IC301
FL OUT
FEED + FWR
RLOUT
FEED - REV CDL IC161 FROUR
FOCUS + CDR
RROUT
PWS FOCUS - POWER AMP
POSITION E-VOLUME
SP + BTL_DMO
SET SWITCH SP - BTL_FMO IC771
FEED +
TRK + BTL_FOO CDL
FEED -
TRK - BTL_TRO CDR EEPROM
FOCUS +
LOAD + Vref
FOCUS - FRONT LEFT(+)
LOAD -
FRONT LEFT(-)
LOAD&FEED
BCK FRONT RIGHT(+)
MOTOR IC540 LRCK FRONT RIGHT(-)
VF1, VF2
DATA REAR LEFT(+)
VT1, VT2 SDA TU/EVOL
SPINDLE+ SCL TU/EVOL REAR LEFT(-)
CD_MD MP3 LSI
SPINDLE- REAR RIGHT(+)
LD
CN101
CN502
TEL MUTE
KEY0
KEY1
SWITCH UNIT
KEY2 *Remark
D+ FREQ SEL
LCDCL
D-
S601 to S617 JS601 IC681 LCDCE CP_SCL
LCD DA CP_SDA
VOL1
CN901
KEY MATRIX REMOCON CP_Reset
VOL2
ENCODER
REMOCON
IC80 SP OUT
(DC CORD)
KEY2 REMOCON
iPOD Coprocessor
KEY1 VOL1
D+ KEY0 VOL2 USB iPod model only
CN603
USB D- IC981
IC603
CN701
CN601
HS_EN1 DC DC
F-AUXL
HS SWITCH USB 5V
F-AUXG
J601
AUX-IN F-AUXR
AUX-R
AUX-G LCDCL
AUX-L LCDDA
LCDCE
IC661
D627 to D654
P2
D656 to D659
LCD
LCD
REAR-R/SUB-R
REAR-L/SUB-L
CONDITION ---FM MODE. AM MODE. ( )CD MODE.
FRONT-R
FRONT-L
2. UNLESS OTHERWISE SPECIFIED.
SUB-R
SUB-L
ALL RESISTORS ARE 1/16W 5% METAL GLAZE RESISTOR.
*
J321
Line Out (Rear) ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTANCE VALUES ARE IN OHM.
L&R / ALL CAPACITANCE VALUES ARE IN uF(P=pF)
Subwoofer L&R ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
3. COMPONENTS IN ( ) INDICATE NOT USE.
REAR-L FRONT-L
KD-R440J,KD-R445/6U SERIES,KD-R444UI
KD-R449EE,KD-R540J,KD-R541E SERIES KD-R646U SERIES KD-R441/2/3E SERIES
MAIN PWB: GEB10343A FRONT-R SUB-L SUB-R MODELS KD-R547EE,KD-R641E SERIES,KD-R440JW KD-R647EE KD-R447EE
TUNER J VERSION OTHERS U VERSION
KD-R446EU,KD-R449E KD-R446EU
REAR-R
LINE OUT * * * * LINEOUT 1 pair 2 pairs NO LINEOUT C2 7pF 7pF 4pF
C331 C351 C321 C341
C254 C253 J321 QNN0874-001 QNN0868-001 X C6 6pF 6pF 4pF
ANT R372 100p 100p 100p 100p
R332
R322
R342
R258
*R352
180
180
TUNER
180
180
0
R257
180
180
R323,R333 0 X L1 0.47uH 0.47uH 1.0uH
J1 C367 * * * *
R331 R351 R321 R341 R320,R321,R322 0 0 L2 1.8uH 1.8uH 3.3uH
*
QNB0358-001 X
*
* R256 R255
0.01 R320 330
22k 22k 22k 22k R330,R331,R332 0 0 X L8 4.7uH 4.7uH X
22k 22k R253 330
0
C21
R357,R358 0 X R1,R2 680k 680k 470k
C17 0.1
0.1
100/16
C368
C22
C24
* *
0.01
C18
4700p R350 R254 330
0.1
R330 330 D321 0 0 X R3 X X 100
0.1
C8
0.1
TU1 R6 220 330 Q321 0 0 X R10 X X 0 ohm
0.01
R335
C10
C11
0.01
C982
C978
C12
0.01
*
R8 22
1
C16
R340
0.01
0 R9
560u
(1/10W)
C320,C330 0 X
560u
0 ohm
3.5V
X 0 ohm
L5
L6
4.7k
R7 220
C19
*
R4
330 C321,C331 0 0 C28 10pF X X
X
2.2V
5.6V
8.3V
3.9V
3.2V
3.2V
0.6V
8.3V
6.7V
8.3V
6.7V
1.4V
3.0V
1.6V
1.6V
3.5V
X 0
0V
0V
0V
0V
0V
7.0V
R340,R341,R342 X L10 NQL103J-10NX X X
0V
NQR0251-002X
NQR0251-002X
0.6V
0.6V
4 5 6
0V
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 R350,R351,R352 X 0 X L981 QQL92AK-220Z QQL92AK-220Z QQLA1AM-220
0V
0V
0V
L11
L12
NAF0029-002X
CHASSIS
IMX9-W
Q251
4 5 6 4 5 6 X
AMSELOUT2
AMSELOUT1
AMIFAGC1
AMSELIN2
AMSELIN1
PLL2
PLLREF
PLL1
VCO
GNDRF
VCC
VREG
VREF
SDA
SCL
DGND
R347,R349 0 X
10/50
10/50
10/50
10/50
TUNER E,EE & UP VERSION OTHERS & KD-R446EU
* IMX9-W
SDATU
IMX9-W
SCLTU
Q321
Q341
D341 X 0 X
3 2 1
IC1 TEF6614TV1S3-X TEF6614TV1S4-X
X
0V
0V
Q341 0 X
D9
* IC1
0.6V
3 2 1 3 2 1
!
C251
C330
C320
C252
FOR KD-R64X SERIES ONLY
0V
0V
0V
0V
C340,C350 X 0 X
0.6V
0.6V
OFFSET
E_MUTE
FLOUT
RLOUT
RROUT
FROUT
RL/SUBL
RR/SUBR
L10
AMIFAGC2
POWER CORD MODELS
AMRFAGC
R9
AMRFDEC
X
FMRFIN2
FMRFIN1
MPXOUT
C341,C351 X
100/16
0
AMRFIN
*
*
GNDRF
C180
MPXIN
* *
4.7k
4.7k
AGND
ROUT
LOUT
10
TEST
XTAL
0.1
RSSI
VCC
QAM1326-001 KD-R440J,KD-R540J,KD-R440JW
4.7k
R347 4.7k
4.7k
4.7k
10/50
10/50
* R3
QEKJ1CM-107Z-S
R252
R251
QAM1328-001 KD-R445/6U SERIES,KD-R444UI,KD-R446EU
0
* R10 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 KD-R54X & KD-R64X
* MODELS
R349
OTHERS
R357
R358
* C2
R324
* L2
C168
SERIES
C172
QAM1344-001 KD-R441/2/3E SERIES,KD-R447EE
0V
0V
0V
0V
0V
100
C26 C1
100
BAW56-TP-X
4.2V
3.1V
3.1V
8.3V
3.8V
3.8V
0.4V
2.0V
3.5V
3.9V
6.0V
6.0V
* L8 IC80 MFI337S3959-X X
0
5V
R333
2.9V
1.8V
470p 1000P
R323
*
*
NOT USED
*
*
E.VOLUME KD-R449EE,KD-R541E SERIES,KD-R547EE
C175
C169
C170
C171
C316
C317
C318
C319
D251
C3 C80 0.1u X
-
C350
C340
R334
C20
12p
D341
D321
R162
R163
R165
BAW56-TP-X
1 2 3
*
*
* * * R751 22K X KD-R647EE,KD-R449E
BAW56-TP-X
-
* L1 * C27
C28
1000P 4MHz
*
*
0.47u
L9
2.2k
*
* 8 7 iPOD QAM1330-001 KD-R646U SERIES
0.22
* R1
* R2
0.1
CN80 QGG2521M1-03 X
1
6 4 0.1 QAM1345-001 KD-R641E SERIES
X1
* R167
* C6
C29
L3 CN81 QGG2504M5-02 X
C5 QAX0952-001Z
C14
C23
C13
L7
C753 0.1u X
4.7u
0.27u 15p
C7
0.22
C4
3.3V
3.3V
3.2V
3.2V
3.2V
4V
4V
4V
4V
4V
4V
4V
0V
L4 IC301
*
QQR1872-001
TU.R POWER AMP. !
TU.L
28 27 26 25 24 23 22 21 20 19 18 17 16 15
TB2931HQ
* R168
R307 0
* R169
WIN_IN
DC_ERR
SDA
SCL
VCC
MUTE/WINTCR
WINTCL
OUTLF
OUTLR
OUTRR
OUTRF
SWL
SWR
GND
0
0
R306
CD.R A9V 0V
BEEP R308 2.2K C305-C308:NCB21CK-224X-A TAB
1
0V
* IC161
S.GND GND
2
C305
0.22 FR- 7.0V
RROUT R362 0
QP2R/Mute
CD.L OUTFR-
3
TUNER CD FRONT AUX
3.2V
CD_PON R366 STBY
4
QD1G
QD2G
QD2G
QD1R
CREF
SE1R
SE2R
SE3R
QD1L
QD2L
SE1L
SE2L
SE3L
C992
5
100p
C312 14.4V
E-VOL IC VCC1/2
MAINGND 1 2 3 4 5 6 7 8 9 10 11 12 13 14 R365
6
IC161 TDA7718B-X TDA7720B-X 0.022
RR- 7.0V
C308
3.2V
3.2V
3.2V
3.2V
CMDREQ 3.2V OUTRR-
7
X
3.2V
3.2V
3.2V
3.2V
R168 0 100p 0.22 0V
R794 C794 FLOUT R364 0
GND
BSIF_REQ
8
R169 X 0
4.7/50
4.7/50
2.2k
RR+ QEKJ1EM-106Z-S 7.0V
DATA 30 R368 OUTRR+
9
3p 10/25
L161
R167 0 X
R160
QTE1V67-475Z
QTE1V67-475Z
C309 6.8V
To SUB UNIT (KD-R54x series)
C307
QEKJ1CM-106Z-S
25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10
GATE RIPPLE
R161
R178 X 0 100p 0.22
RLOUT R363 0
* R178
10k
1
6.9V
C161
C173
R177
!
(GEA10354-03A)
BCK INRR
C175 X 0
* C166
6.9V
0.1
R367
C162
C174
LRCK INFR
RR/SUBR
C169
RL/SUBL
DC_ERR
0 X 0V
E_MUTE
FAUX-G
FAUX-R
FAUX-L
RROUT
FROUT
C160
RLOUT
FLOUT
10/16
CMDSO 100p PRE-GND
CD.R
TU.R
C170
CD.L
TU.L
0 X
C177
C179
1
FOR KD-R646UP ONLY 6.9V
CMDSI Pin 24 INFL
8.3V 11.4V
voltage TP4 6.9V
CMDBUCK C313 INRL
To ELECTRIC UNIT-2
RESET
BU_DET
E_MUTE
MUTE
AMP_MUTE
OFFSET2
AMP_STBY
OFFSET
6.9V
CMDCCE AC-GND
1
(GEA10343-xxA)
RL+ R310 6.9V
CDRESET NCB21AK-105X-A OUTRL+
5.1 0V
SRAMSTB GND
RL- (1/8W) 7.0V
CDMUTE OUTRL-
C311
14.4V
BTLGND R302 47k VCC3/4
FL+ 0.022 7.0V
R304
CD8V OUTFL+
C315
3.6V
0
FWD MUTE
1
LINE MUTE FL- 7.0V
REV OUTFL-
DETAIL DEBUGGING R303 0V
USE ONLY R783 100K
DRVMUTE GND
3.3V
SW3 OFFSET
BAW56-TP-X
3.3V Q782 R780 47k
D780
LTA024EUB-X
3.3V
SW1
-
TP7
TP9
D782
10k
47k
3.3V POWER IC MUTE
3.3k
3.3k
3.3k
3.3k
0.1
TP10
47k
47k
22k
47k
47k
SW2 0V RKS801KF-X R781 330
LTA024EUB-X
TP6
TP8
3.3V
C314
1
Q780
C727
R739
C752
R750
R749
R751
R754
R753
R731
R728
R735
R736
R727
C977
C713
10K
HC3-4 470p 0V L901
* C753
BAW56-TP-X
D783
*
TRDA3
TRDA2
TRDA1
TRDA0
TRCLK
3.3V
D781
BAW56-TP-X
C728
QQR1884-001
10
0.1
0.01
C729
C917
C916
100p
100p
R784
0V
2700/16
C901
D705 Q781
1N5401-BPC04
NAF0029-001X
QEZ0937-278
LTC024EUB-X NOT USED FOR KD-R441/2/3E SERIES & KD-R447EE
RKZ6.2B2KG-X
RKZ6.2B2KG-X
47k
47k
USBPON
SDACP
BSIF_REQ
RSTCP
SCLTU
SDATU
CMDREQ
DRVMUTE
GATE
REV
FWD
BU_DET
CMDBUCK
CMDSI
CMDSO
CMDCCE
CDRESET
CDMUTE
CD_PON
SRAMSTB
SW3
D901
!
R723
47k
C998 REMOTE OUT
SCKCP
D111
D101
0.01
SWCLK
SWDIO
C997
R726
R722
R752
10k
CN81
1
CN80
MBRX130-TP-X
4.7k
C708
C941
C942
C733 2
0.1
D942
0.1 R786
0.1
10
RKZ6.2B2KG-X
RKZ6.2B2KG-X
2 * R777
(1/8W)
3
R941
RSTCP
AUDIO OUT
FOR KD-R446UP & 10K
C711
ANT OUT
C112
ACCOUT
1K
ILM OUT
AUDIO F
KD-R646UP ONLY C101
CD OUT
R112
ACC IN
VDD5V
CTRL2
CTRL1
FAUX-L C712 X702
D110
D100
SW5V
D941
ILM F
GND
CD8V
R788
* D704
GEA10354A
VCC
QAX0401-001
EXT
RKZ6.2B2KG-X
R100 470p
0 1 OE
C702 MBRX130-TP-X
1000p
C100
R101
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
47K
CN701 18p
C900
0V
11.5V
0V
(3.3V)
(3.3V)
(3.3V)
(3.3V)
(3.3V)
(3.3V)
(3.3V)
(3.3V)
8.4V
(3.2V) 1.6V
3.3V
4.9V
4.9V
4.9V
4.9V
QGZ1102J1-20 FAUX-R TELMUTE
14.3V
14.3V
14.3V
1.6V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
1.2V
1.3V
(0V)
(0V)
(0V)
(0V)
(0V)
1.5M
R110 ANT
1V
0V
0V
0V
0V
0V
C701 R907 R905 ACC IN REMOTE
AUX-L 1 C111 10K BACKUP
(7.9V)
18p U VERSION &
C110
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 ILL
1000p
R111
C915
0 1
47K
KD-R446EU ACC
AUX-R 2 R102 0
C102
SW3(LOAD END)
XT2
XT1
REGVCC3
NC
USB_PON
SCL CP
SDA CP
BSIF-REQ
CP RESET
CMD_REQ
DRVMUTE
GATE
REV
FWD
SWCLK
SWDIO
DVSS
DVCC3
BU_DET
CMD_BUCK
CMD_SI
CMD_SO
CMD_CCE
CD_RST
CD_MUTE
PON_CD
SRAMSTB
FAUX-G R909 VDD5V (1/8W)
R990
AUX-G 3 27k
MBRX130-TP-X
0
R792
D851
1
10/25
KEY2 D903
6.8k
6.8k
GND 4 0
Q701
3.3V 3.3V SW2
QNZ0607-001
KEY2 5 X701 4.7V IC931 D902 ANT
C718 0.47 81 CVCC3 50 L701 ACC5V
R902
R901
C724 QAX0968-001Z SW2(EJECT END)
11.5V 6 1.5V 3.3V SW1 4.7u VDD3.3V
XC6213B332NG-X
RL-
RR-
RR+
82 X1 SW1 49
FR+
FR-
FL-
FL+
RL+
10/25
C911
C902
REMOCON
CN901
47/16
FOR KD-R64X SERIES ONLY
4.7k
15p R721 0V 3.3V PSW
330/6.3
10/25
R906
5.6K
MBRX130-TP-X
330/6.3
REMOCON 7
100/16
47/16
C909
1M 83 CVSS PSW(RST SW) 48 4.7V
U VERSION &
0.1
R988 0 RGBCLK C725
0.1
0.1
C851
R782 1.5V 3.3V AMP_MUTE CTRL VIN
4
NC 8
KD-R446EU
To SWITCH UNIT
84 X2 AMP MUTE 47 3.3V
10
11
12
13
14
15
16
17
18
VOL1
C980
C705 0.1
9
12p 820 3.3V 3.3V MUTE GND VOUT
D852
R851
2
3
VOL1 9
10
C913
C906
C908
85 DVCC3 RCA MUTE 46
4.7k
C931
C912
C905
C910
C904
R908
(GEA10344-xxA)
C907
C932
C933
C903
VOL2
0.1
0V C731
330
VOL2 10 C703
86 DVSS NC 45 0.1
LCDCL 0.01
CN601
27
QMFZ064-100-J1
15k D+ R789 0V (3.3V) HC3-4
LCDCL 11 R775 D902/D903:MBRX130-TP-X
87 D+ HC3_4 44 R534 47k
100/16
LCDCE 27 SW3.3V
C704
LCDCE 12 R776 15k D- R790 0V ! 3.3V 3.3V
88 D- NC 43
LCDDA
3.3V AMP_STBY SW3.3V
F901
2SA812A/5-6/-X
0.1
*
GND
ACC
REMOTE/P-con
ANTENNA
FRONT RIGHT(+)
FRONT RIGHT(-)
FRONT LEFT(-)
FRONT LEFT(+)
REAR LEFT(+)
REAR LEFT(-)
REAR RIGHT(-)
REAR RIGHT(+)
OE REMOTE
TEL MUTE
ILL
MEMORY
FUSE 10A
USBGND 14 3.3V DIMMER_IN
90 NO USE DIMMER 41 2.6V R952
ILMI
TEL MUTE
D+ R759 47k R748
R891
3.3V
D+ 15 IC701
R881
TEST5
C954
10k
91 NO USE NC 40
!
R882
330
27k
R951
1K
D- R737 910
4.7k
RGBCLK 0V 0V SN
D- 16
VFD_INH
92 RGB_CLK JCV8019 NC 39 R742 47k
0V
0V 3.3V *
MC2836-X
HS_EN 17 R757 100k TEST4 Q952 5.0V
VOL2 93 ENC2 NO USE 38 3.3V
R795 10k 3.3V 0V LTC044EUB-X
USB5V 18
D891
94 AVCC3 SN 37 SW5V
KEY0 C716 0.1 0V
KEY0 19 TELMUTE 1.48V 0V R894 0V
95 TEL MUTE DVSS 36 TELMUTE
C714
OPEN
KEY1
R883
KEY1 20 TP12 * 3.3V
96 STAGE 2 DVCC3 35 0.1 TM 0
10k
C891
R893
R892
R743 47k
68k
12k
KEY2 R733 * 0V 0V
(1/8W)
0.1
C881
22/16
97 STAGE 1 TEST1 34 Q881
R791 0 4.7K
VOL1 VFDCE 3.3V 3.3V OFFSET2
AUX-R RGBCLK D+ VFDCLK KEY0 USBGND 98 KEY2 NC 33 DIMMER_IN LTC014EUB-X
AUX-G
R980
R979
BU.DET
R724 L981 R985
4.7K 22 R973
FREQ_SEL
VFD_INH *
R970
ACC DET
47k
KEY2 REMO USB5V 0.1
/RESET
REG1-2
REG2-2
REG1-3
REC2-1
VREFH
LCDCE
LCDDA
10K
LCDCL
C990 0.1
MODE
REMO
20k
R987
DVSS
ENC1
AVSS
BEEP
LRCK
DATA
NC
NC
NC
NC
NC
NC
NC
NC
LSCR523UB-X
LSCR523UB-X
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 0V 2.9V 47k
LX VCC D971 (1/10W)
8
0V
0V
0V
0V
0V
0V
0V
0V
0V
0V RKZ6.8B2KG-X
0V (3.3V)
Q971
3.3V
3.3V
3.3V
3.3V
3.3V
1.6V
3.3V
3.3V
3.3V
3.3V
TP11 LTC044EUB-X
(0V)
Q970
GND BST
(3.3V)
(3.3V)
7
1.1V 4.8V
VC EN
6
R972 0V
910
R702 2.2K
* R764 R981
R772 4.7k
R706 910
47k
0
R974
47k
NQR0154-006X FREQ_SEL FB SYNC 10k 47k
L982
4.7
4
5
R770 4.7k
R774 4.7k
R771 4.7k
*MODELS
R701
R709
10k
DB22306-X
R965
6800p
C983
KD-R446U L704
* R738
110K
KD-R442E
L704
L703
L702
10
10
R704
R796
KD-R443E
10
KD-R446EU
10
R758 100k
BD9673EFJ-X
R962
SCLTU
SDATU
4.7k
R982
R986
C986
27K
STAGE 1 1.5V 0.6V 0V 1.8V 1.5V BU DET SURGE DET 22k
C987
C981
RXM
C985
R747 24k R474
C989
R766 22K 8.2K 47K 27K 22K C722
270
EPROM
D981
R769 0
R983
R765 TXM
270
REMOCON
C963 3.2V 0V
R779
R746 47k
VFD_INH
DC_ERR
SDA GND
LCDDA
LCDCL
LCDCE
R705 2.2k
BEEP
LRCK
DATA
VOL1
KEY0
3.2V 0V
BCK
3
3.3V
3.3V
0V 0V
KD-R440JW WPIN A1
7
3.2V 0V
RESET
CNDET
SDATU
SCLTU
RESET
2 1 VDD A0
R745
DC-DC USB5V
8
1
100
IC702
C723
R765 39K X 39K 22K 22K SDA
0.6V C994 0.047 (WITHOUT OE/ WITH (WITHOUT OE &
STAGE 2 0V 0.6V 1.8V 1.8V
QSW0648-001Z
TP15 REMOTE)
C706
C707
IC771
47K
KD-R441/2/3E SERIES
47k
0.1
C991
C999
KD-R444UI,R449EE,R540J,R449E KD-R447EE
470p
GND
0.01
0.01
3 4
*MODELS
* R787
R730
0.0V
0.0V
R720
R725
VDD 0.01
C996
R738 2.2K 2.2K 0 ohm When replacing those parts make
R764 22K 27K 10 R787 27K 22k 22k
STAGE 1 1.8V 1.8V
R766 27K 22K
R777 sure to use the specified one.
0 X X
R765 22K D704
1.8V 39K
STAGE 2 0.6V CHASSIS
R767 27K 8.2K
FOCUS-
FOCUS+
TRK+ R504 270k
TRK-
BTL_TRO
R506 30K
BTL_DMO
TSDO VREF
R595
C511
C512
R516 33k DSPR
R517
C504 0.1 2K
1000P
C583
C592
100P
CD.R
S.GND
3.6V
3.6V
3.6V
3.6V
3.6V
1.6V
1.6V
1.6V
1.6V
7V
0V
0V
0V
0V
7V
0V
0V
CD.L
44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23
1000P
C582
C593
100P
VO3+
VO2-
VO2+
VO1-
VO1+
NC
NC
NC
PGND2
VM2
VIN1
VIN2
VIN3
NC
VIN4
NC
SWREG
GND
FB
REG0
VREF
TSDO
CD_PON
C581
470p
R596
DSPL VDD5V
IC501
! 2K
MAINGND
LV8281VR CMDREQ
VCONT
PGND1
BSIF_REQ
REG5
VO4+
VO3-
VO4-
FWD
CPC
VCC
VM1
REV
EN2
EN1
LO+
LO-
NC
NC
VG
NC
NC
NC
CP
DATA
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 GATE
0V
0V
0V
7V
0V
0V
0V
0V
7V
5V
BCK
3.6V
3.6V
3.6V
3.6V
3.6V
9.7V
3.5V
1.4V
4.4V
3.3V
12.5V
LRCK
C503
CMDSO
CMDSI
47K
To ELECTRIC UNIT-1
C505 R519
0.1
C510
C509
C508
0.047
CMDBUCK
33K
(GEA10343-xxA)
R514
C506
CMDCCE
0.22
R501
110K
CDRESET
C507
R510
SRAMSTB
FEED+
CDMUTE
FEED-
BTLGND
C513
C514
100
100/10
0.1/16
R518
CD8V
C501
0.1
SP- FWD
SP+ REV
DRVMUTE
SW3
LOAD+ D502
SW1
LOAD-
GS1J-LTP-X SW2
CN502 VF1
PSW
QGF1040F1-26
100
100
SW3
HC3-4
VF1
VF1 1
SW3
SW3 2 SW2
FWD R502
R503
DRVMUTE
D3.3V 3
LOAD+
FEED+
LOAD-
FEED-
SW2 VF2
REV
SP+
SP-
SW2 4
VF2 SW1
VF2 5
SW1 VT2
To CD PLAYER UNIT
VREF
SRAMSTB
CDRESET
CMDCCE
CMDBUCK
CMDSO
CMDSI
CD_PON
SW1 6
R576
VT2 PSW
VT2 7
(LVA11003-03A) PSW 8
10K
R577 C576
PSW
VT1
R575
(FLM-HC3-1D) VT1 9
10K C575
VREF
3.3k
HC3-4
CN101
VREF 10
1500p CD_MD
MD 11 R535
C516 0.1
GND 12
HC3-4
HC3_4 13
LOAD-
LOAD- 14 VREF
LOAD+
LOAD+ 15
C571
47p
SP+
SPINDLE+ 16
SP-
SPINDLE- 17
(LVA11003-05A)
FEED-
FEED- 19
C566
R574
0.1
15K
(FLM-HC5-1D)
0.1
0.1
0.1
GND 20
1
100K
10K
10K
10K
100
100
100
100
LD 21
0.01
CN101
0.1
C568
C567
330K
IC530
R573
C570
C569
GND 22
BU33TD3WG-W
TRK-
C572
TRK- 23
0.015
C574
C573
R572
TRK+
R571
R570
R569
R568
R567
R566
R565
TRK+ 24 4.6V 3.3V
D3.3V
C531
FOCUS- VIN VOUT
5
0.1
FOCUS- 25 0V
1.5V
0.9V
1.6V
1.4V
1.6V
1.6V
1.6V
1.5V
3.3V
2.5V
3.3V
2.5V
3.3V
FOCUS+ GND
2
0V
3.3V
0V
0V
0V
0V
0V
FOCUS+ 26 3.3V
C530
STBY NC
1
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
R539
R530
VCoF
PVREF
LPFo
LPFN
TMAX
PDo
VDDM1
/SRAMSTB
VSS-1
VDD-1
TEST
/RST
MS
/CCE
BUCK
BUS3
BUS2
BUS1
BUS0
VDD3
0
R533
C540 0.1 R540
0
C541 2200p 220 1.3V 0V
IC531
60
VCOI Pio7
1
BU15TD3WG-W
C542 0.1 3.3V 0V R520 3.3k LRCK 4.6V 1.5V
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59
RVDD3 Pio6
2
C533
VIN VOUT
D1.5V
1
5
0.01 1.6V 3.3V R521 BCK
0.1
C543 680 0V
SLCO Pio5
3
GND
2
C544 3300p 1.6V 3.3V R522 680 DATA
Pio4 3.3V
ARF RFI
C532
4
STBY NC
1
3
4
C545 0.1 1.6V 0V
D1.5V
R531
10K
RFRPI Pio3
5
0.1 ! BU15TD3WG-W
C548 68p 1.3V 0V
VSS-2 4.6V 1.5V
RF RFo IC540
9
BU1.5V
0V 1.5V C565 VIN VOUT
5
JCV8022 R557
C535
20 19 18 17 16 15 14 13 12 11 10
RVSS3 VDD1-2 0V
0.1
0.1
QAX0929-001Z
1
1.6V 3.3V GND
2
16.9344MHz
470
C534
FNi2 XVDD3 4.6V
0.1
X540
2
VF1 1.9V 1.5V C564 STBY NC
4
R558
FNi1 Xo
1M
0.1
3
1.6V 1.4V
FPi2 Xi
VF2 1.8V 0V
FPi1 XVSS3
VT2 1.9V 0V R556 0
TPi DVSS3L
4.7
0.1
TNi Lo L561
10
VT1
R547
VRo DVDD3L
0V 3.3V C561 10
R548
C550
C551
AVSS3 DVDD3R
R545 2.2M 0V 1.7V L562
Pio12/CDMoN0/FGiN
3.0V MDi Ro
R549 1K NQR0154-006X
Q540 2.2V 0V
LDo DVSS3R
Pio13/CDMoN1
Pio14/CDMoN2
2SA2188/F/-X
R555
2.4V CD_MD
1.8V L531
FSMoNiT
CDMoN3
4.7
VDD1-3
AVDD3
VSS-3
RFRP
FMoS
Pio10
Pio11
CD_MD
RFZi
DMo
FMo
Pio8
Pio9
TRo
R554
Foo
TEi
NQR0154-006X
4.7
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
FE
0V
0V
0V
0V
0V
0V
0V
0V
0V
1.6V
1.9V
1.6V
3.3V
1.6V
1.9V
1.6V
1.6V
1.5V
RKS801KF-X
D540
4.7K
R550
/DET
C552
0
0.033
FOK IPT
R509
R508
R513
R512
TE
LASER DIODE CIRCUIT
C553 4700p
47K
C558
0.1
C554 330P
C559
0.1
C555 680P
C556 0.068
R553
C557 0.033
BTL_DMO
BTL_FMO
BTL_FOO
BTL_TRO
CDMUTE
DSPR
DSPL
IPOD CP CIRCUIT
IC80
*
MFI337S3959-X
CN80 CN81
*
*
QGG2521M1-03 QGG2504M5-02
NC NC
4
3.3V
3 SCL NC 2 To ELECTRIC UNIT-1
3
To ELECTRIC UNIT-1 0V 3.3V (GEA10343-xxA)
(GEA10343-xxA) 2
7
RST SDA 1
CN81
2
3.3V 0V
CN80 1 VCC GND
8
1
* C80
0.1
COM1
COM4
COM3
COM2
S50
S40
S41
S42
S43
S44
S45
S46
S47
S48
S49
LCD DISPLAY
40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
* D681
P C672
4700P
C671
4700P
* L670
(1/8W)
R681
* L673 CN601
QGZ1102K3-20X
*
AUX-L
1
* L674
AUX-R
2
D682
AUX-G
3
* DI1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 * GND
4
KEY2
R677 1.5 5
(1/8W)
C665 1 11.5V
6
JS601 R676 1.5 (1/8W) REMOCON
QSW1299-001 7
SW R679 NC
5 6 8
VOL1
4 7
ENCODER 9
To ELECTRIC UNIT-1
VOL2
10
1 2 3
A B LCDCL
SELECT
VOL2
LCDCE
12
11
(GEA10343-xxA)
CN701
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
S31
S32
S33
S34
S35
S36
S37
S38
S39
VOL1 LCDDA
S1
S2
S3
S4
S5
S6
S7
S8
S9
13
USBGND
14
COM1
COM2
COM3
COM4
S50
S49
S48
S47
S46
S45
S44
S43
S42
S41
S40
S39
S38
S37
S36
S35
S34
S33
D+
C601
C602
15
RKZ5.1B2KG-X
RKZ5.1B2KG-X
RKZ5.1B2KG-X
D-
16
D664
D663
D662
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
LIGHTING DISPLAY HS_EN
17
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 USB5V
18
KEY0
19
KEY MATRIC KEY1
R617 20
R661
(1/8W)
(1/8W)
R660
51 30 R615
2.4V 2.4V S29
* * 52 29 10K
2.4V 2.4V S28
53 28 R616
2.4V 2.4V S27
S603 S602 S601 54 27 0
LCD DRIVER
C604
(1/8W)
R640
910
910
R637
R638
R639
R643
R644
R645
R646
R647
R648
R649
R641
R642
R650
R651
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
(1/8W)
R655
R656
(1/8W)
55 26
VDD1 3.2V 2.4V S25
* * * * * * * * * * * * * 56 25
* *
IC661
(1/8W)
(1/8W)
1.7V 2.4V S24 C607
F-SKIP B-SKIP POWER/SRC VDD2 5V 5V
57 24 VOUT VIN
5
R662 R663 0V 2.4V S23 0.01U
PT16580-LQ
GND
2
3.3V
58 23 OC EN
4
R665 100
F.SKIP
F.SKIP
1K 1K LCDCE 2.4V 2.4V S22 C606
D619
D621
D639
D623
D641
D625
D643
D627
D645
D629
D647
D631
D649
D633
D651
D635
D653
DISP
DISP
PWR
PWR
0.01
59 22 IC603
VOL
VOL
VOL
VOL
VOL
R664
RKZ5.1B2KG-X
R666
1K
2 2 4 4 6 6 LCDCL 100 2.4V 2.4V S21 470P TPS2065CDBV-X
R609 R608 R607 R604 R606 R605 KEY1 * * * * * * * * * 60 21
D660
* * * * * * * *
LCDDA R667 100 2.4V 2.4V S20
LWY1SG/45/Z1-X
NAF0029-001X
B.SKIP
B.SKIP
2.7k 820 820 61 20
MENU
MENU
10K 3.9K 3k
EJECT
EJECT
C661
C662
BACK
BACK
D620
D622
D640
D624
D642
D626
D644
D628
D646
D630
D648
D637
D655
D632
D650
D634
D652
D636
D654
D638
D656
P1 5.1V 2.4V S19
VOL
VOL
VOL
VOL
VOL
D657
BACK LIGHT
PWR
USB
EQ
EQ
D659
D661
C663
1 1 3 3 5 5 62 19
C664
*
0.1
0.1
* * * * * * * * * * * * * * * * * * * * * P2 5.1V 2.4V S18 LF691
* 63 18
P3 5.1V 2.4V S17
64 17 2 3
S608 S607 S604 S606 S605
C603
0V 1 4 R691
Q633 R652
0.78V NQR0536-001X 10K
EJECT DISP EQ MENU BACK
C691
LSCR523UB-X 2.7k
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 10
0.2V
* Q632 * R653 4 VCC
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
0.6V RED/AMBER/BLUE
2.4V
2SC6046-X
3 D-
R614 R613 R612 R611 R610 KEY2 0.2V
S10
S11
S12
S13
S14
S15
S16
* Q631 2 D+
S1
S2
S3
S4
S5
S6
S7
S8
S9
2SC6046-X
2.7k 1.8k 1.2k 820 820 0.6V * R654 GREEN
1 GND
R678 C680
0
CN603
C679 27p QNZ1076-001
D691
D692
RKZ5.1B2KG-X
RKZ5.1B2KG-X
6 5 4 3 2 1
S601~S614: NSW0246-001X
R638~ R642
R660 470 ALL RESISTORS ARE 1/16W +5% METAL GLAZE RESISTOR.
680
330
D639 - D656
BLUE AMBER RED RED
430 430 ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
R645~ R647
-
QSMR-C13/BCMN-X SML-311WT/JK/X SML-D12V8W-X SML-D12V8W-X ALL RESISTANCE VALUES ARE IN OHM.
R661 470 -
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
Q631
- - - 2SC6046-X 2SC6046-X
R654
C662 1U 0.1 U R643, R644 1.2K 1.2K 2K ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
T --- TANTAL CAPACITOR.
- - - 1K 1K
-
IC681 KSM-2003TN5B -
R648, R649 1.2K 2K 2K 3. COMPONENTS IN ( ) INDICATE NOT USE.
R637 - - 430 430
0.1U
C682 -
R655-R656 - - - 1.2K 1.2K KD-R445U, KD-R446U, KD-R444UI KD-R440J, KD-R540J, KD-R541E, KD-R547EE
D681 RKZ3.3B2KG-X - MODELS KD-R441E, KD-R442E, KD-R447EE
KD-R449EE,KD-R446EU,KD-R449E
KD-R440JW
KD-R443E
PICKUP A'SSY
OPTIMA-750B1 LVB11141-A1
SL1
5 4 3 2 1
CN102
VF2 QGF0522F3-15W VF2 VF2
1 1
HDU-120 Vcc
2
Vcc VCC
2
VT2 VT2 VT2
3 3
LD LD LD
6 7 8 9 10 4 4
GND GND
5 5
VT1 VT1 VT1
1 6 6
Vc Vc VC
7 7
MD MD MD
8 8
0.1
VR VR R1 130
0.1 9 9
1k VF1 VF1 B1 VF1
10 10
GND GND 0
11 11
TRACKING- TRACKING- TR-
12 12
TRACKING+ TRACKING+ TR+
13 13
FOCUS+ FOCUS+ FO+
14 14
FOCUS- FOCUS- FO-
15 15
SPINDLE
FOCUSING COIL TRACKING COIL MOTOR SP+ SP+
SP- SP-
CN101
QGF1044F2-26X
FO+
LVB11141-A2 1 FOCUS+
SW4 FO-
2 FOCUS-
NSW0291-001X TR+
3 TRACKING+
REST REST TR-
4 TRACKING-
REST SW MGND
5 GND
LD
6 LD
7 GND
FE-
8 FEED-
FE+
9 FEED+
SP-
10 SPINDLE-
FE+ FE+ SP+
11 SPINDLE+
FEED
FE- FE-
SL2
LO+
12 LOADING+ To ELECTRIC UNIT-2
MOTOR LO-
13 LOADING- (GEA10343-xxA)
14 SW GND CN502
15 SW GND
MD
16 MD
VC
LO+ LO+ 17 VREF(Vc)
VT1
LOAD LO- LO- 18 VT1
MOTOR REST
19 PSW/REST
VT2
20 VT2
SW1
21 SW1
SW1 VF2
22 VF2
SW2
1
SW1 23 SW2
VCC
NSW0291-001X 24 Vcc
SW3
3
25 SW3
VF1
26 VF1
SW2
NSW0291-001X
SW2
SW3
SW3
NSW0291-001X
PICKUP A'SSY
OPTIMA-750C2 LVB11141-A1
SL1
5 4 3 2 1
CN102
QGF0522F5-15W
VF2 VF2 VF2
1 1
HDU-120
Vcc Vcc VCC
2 2
VT2 VT2 VT2
3 3
LD LD LD
6 7 8 9 10 4 4
GND GND
5 5
VT1 VT1 VT1
1 6 6
Vc Vc VC
7 7
MD MD MD
8 8
0.1
VR VR R1 130
0.1 9 9
1k VF1 VF1 B1 VF1
10 10
GND GND 0
11 11
TRACKING- TRACKING- TR-
12 12
TRACKING+ TRACKING+ TR+
13 13
FOCUS+ FOCUS+ FO+
14 14
FOCUS- FOCUS- FO-
15 15
SP- SP-
CN101
QGF1044F3-26X
FO+
1 FOCUS+
FO-
2 FOCUS-
LVB11141-A2 TR+
3 TRACKING+
TR-
4 TRACKING-
SW4
NSW0349-001X 5 GND
LD
REST REST 6 LD
FEED
FE- FE- LO-
13 LOADING- To ELECTRIC UNIT-2
MOTOR 14 SW GND (GEA10343-xxA)
15 SW GND CN502
MD
16 MD
VC
LO+ LO+ 17 VREF(Vc)
VT1
LO- LO- 18 VT1
LOAD
REST
MOTOR 19 PSW/REST
VT2
20 VT2
SW1
21 SW1
SW1 VF2
22 VF2
SW2
1
SW1 23 SW2
VCC
NSW0349-001X 24 Vcc
SW3
3
25 SW3
VF1
26 VF1
SW2
NSW0349-001X
SW2
SW3
SW3
NSW0349-001X
B115
B116
B922
C910
C908
B921 1
B919
C901 J321
CN901
B307
IC301
C350
C330
B251
C309
B920 B306 B1
D901
C907
B302
L901
B303
IC901
C340
C320
C252
C251
B188
B305
B925
B918
B901
B910
B911
B933 B166
B902
B903
B904
B528
B304
B906
B163
B309
C906
B164
B182 J1
B552
B178
B192
B311
C904
1
C172
B171
B908
B913
C913
C932
B172
B775
B191
B308
C881
C160
C704
B787
B788
B917
C903
B761
B924
B10
B104 B190
B167
B6
B784
B103
B165
B174
B905
B102
B774 B186
B175
B772
B551
B793
B105
B169
B783
B543
L4
B771
B173
B168
B106
X1
B766
B781 B792
B176
B538
B315
C24
B777
B503
C162
B5
B4
B764
B776
C174
GEA10343- A
B534
B790
B9
B763
B539
B179
B535
B531
B532
B101
B111
B909 PbF B537
B112
X702
B177
B533
B529 B113
B301 UL MARK
B760
B114
B184
B540
B914
B117
S1B B100
B310
X701
B782
B791
B107
X540
B780
L981
B108
CN81 B109
C514
CN502
B768
B767
B183
B779
B170
B773
CN80
B795
B796
B797
B3
B527
B180
B181
C963
B110
B765
CN701 S701
B762
D852
C851
R851
D851 L902
Q341
R330
R350
C979
D782
C902
R780 R443
R781
C314
C312 C315 R941
CN901 R902
TP3
C311 IC301
D942
BACKUP
C942
R352
C351
J321 1
C916
F101
R351 TP4 REMOTE
L901
R901
C910
R307
C368 D941
C901
C908
C313
C367
C978
R450
R308
D901
C909
R905
R306
R302
B R473
R496
R788
R777
R478
R310
M
C907
R304
IC901
D902
D704
R258
C254
C331
R332
R254 D903
R251
VDD5V
C330
C309
C350
R321 R441 R256 R331 R906
R990
A R252 A C941
Q251 R335
C982 R303
L
M
Q881
R883
C731
R347
C911
R401
R774
R770
R738
R787
R349
D341
R253
R881
R255
R257
C253
R322
C321
C341
R342
R433
R456
R364
R368 R479 R471 R428 SW5V
R773
R771
R341
L702
L703
L704
C906
R363
R367
C307
C308
ACC5V
R432
R718
R440
D9
R730
J1
C251
D251
C252
C320
C915
R447 C316 R743
C317 R475
C932
C931
R334
CD8V
R474
C905
C904
R408
C917
D321 C340
R909
K
1
C318
R420
R362 R457
R366 R405 D502
C170 R974
C913
C933
R426 R908
C305 R975
C169 R976
R952
C17 R333
R882
Q951
R973 D971
L701
D970
C10
C306
R323
R971 Q971
C18
IC931
R4
Q970
L5
C171
1
R162
C175
R972
R361
R365
R324 L D783 R778 IC771 R907
C16
C19
C12
C168
C166
R2 R358
Q321
R320
R893
C172
C5
R372 R357
C6
C903
C703
C912
R8 D780
C8
C954
Q782
Q952
C881
C2
L1
R472
R165
R163
R167
D781
C22
R168
D891
R894
C180
L9
C21 R6
R892
R891
1
R497
C704
1 R169
C11
Q781
IC161 C991
R779
L6
R419
C160
R477
R161
R793 C891
Q780
R3
L2
C27
R769
R704 R490
R709
R701
C179 R703 R468
R7
R160
L161
R178
R177
C727
R705
R772
R417 R747
R431
R467
C177 R794 R453
IC1 R483 C723
C794
C3
R783 R754
R444
X1
C535
R753
IC532
R720
R574
R573
C534
R784
R970
SDA
C572
R702
SCL
D3.3V
1 R748
C707
R12 R706 R746
C4
TM
ACC
BU DET
IC702
DET
IC530
R530 R726
C530
C23 C14 C20 C531 R722
C15
C542 C573
R725
RST
L12
R423
C541 C574 1 R723 RXM R796
C13
C7
1
C720
L11
ARF TXM
C173
L4 R732
C161
C544
C24
R742
R763
R762
L7 C545
R442
R534
C717
R724
C546
C547
1
1
R712
C549
C548
C575
C576
R758
K VDD
R576
R577
R571
R410
3.3
R9
R572
C29 R545
FL11.5V
R10
R438
L8
C714
R739
R768
R461
C26
RF IC540 R744
C553
C552
C1
L3
C162
R566 C567
R549
R509
R508
R513
R512
C559
R520
R521
R539
C557 C558
R791
C174
R465
R733
R402
C712 C989
R414
R727
R764
R505
R506
R517
R507
R987
1
A9V R504 R765
R522
R767
IC701
C985
R547
R546
C550
C566
R565 C713
C788 C986
C551 X702 C984
C564 C565
R979
SWDIO
C701
R430
C702
C990
R749
R750
C718
R757
R548
R556
C977
R741
R740
D981
R985
R403
R570
X540
Q540
C725
L561 R567
D540 R560 SW3.3V
L562
R569
R557
R550
1 IC981
C705
C724
R776
C555
X701
R553
R731 C728
CN81
L981
R448 R721
R982
R986
C504 R555
C513
R766
R516
C732
C716
C561 PANDET
R400
R554
C752
R514
CN502 L531 R751
C980
C507 R752
R789
R790
R737
R795
C516
R533
R451
C101
C102
C111
C753
C999
R439
R595
R792
R988
C512
C987
R980
C511
C592
R411
C110 R785
CN80
C583 1
1
C510
R510
C995
R111 C722
Q701
R983
R460
C582
C729
IC531
IC501
C532
C983
R735
R531
C533
C994 R786
R736
R101 C509
C505
R452
R112
C112
R962
R981
USB5V
C593
D100
C708
C963
C100
R518
R596
R449
C992
C993
D110
C508
R745
C581
C503
C501
C996
R519 CN701
R100
R102
R110
D101
D111
R501
C706
R502
C506
R503
P1B
T1B
R495
GEA10354A F1A
CN80
S1A
CN81
C80
1
IC80
X89-3130-10
GEB10354A
UL MARK
CN80
CN81
T1A
W
K
P1A
D625 D638
D643
R609
S607
S606
R608
R607
S608
S603
D656
D619
R605 D626
C603
D644 R603 D640 D620 GEA10344- A
R606
R604
D647
D629
C604 IC681
S601
R651
R650
D659
D627
R638
D645
D657 S1A
R601
CN603
D639
D621
D623
D641
D630
D648
JS601
R645
DI1 D633
D631 D632 S610 D634 D635 D636
R610
R611
R612
R613
D637 D649 D650 D652 D651 D653 D654
S604 S609 S611 S612 S613 S614
D622 D642 D624 R614
S602
D655
R649 T1A
R648 P1A
ULMARK
CN603 R617
PbF
C607
C606
C608
R618 R637
D681
C601
C602
R616 R640
JS601
GEB10344A R682
LF691
D692
C665
C682 IC603 R642 R641
IC681
R691
C691
R644
R679
R660 Q633 Q631 R643
IC661
C680
R676
R661
C679
D691
R677
R675
R678
R681 CN601
D660 R655
R652
R654
R653
D661 R656
1
J601
R615
C605
Q632
R647
R646
R672
C672
R662
D682
L674
C661
R667
L670
R666
R665
D662
D664
D663
R671
C671
C664
R663
R664
C663
C662
L673
SL1
A1
CN102
2
10
CN
LVA11141-
R1
B1
B1
R1
P2A
CN101
CN101
SW3
SW3
SP-
BLK
FE+ PbF
YEL
ULMARK
SP+ REST
RED MGND
ORG
ORG
FE- WHT
SW2
SW1
LO-
WHT
LO+
YEL
SW1
SW2
(No.MA538<Rev.003>)16/19
CD PLAYER UNIT-2 LVA11003-03A (LVB11141-001A)
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
P2A
SW4
SW4
PbF
LVA11141-A2
(No.MA538<Rev.003>)17/19
CD PLAYER UNIT-1 LVA11003-05A (LVB11141-001A)(FLM-HC5-1D)
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
SL1
A1
CN102
2
10
CN
LVA11141-
R1
B1
B1
R1
P2A
CN101
CN101
SW3
SW3
SP-
BLK
FE+ PbF
YEL
ULMARK
SP+ REST
RED MGND
ORG
ORG
FE- WHT
SW2
SW1
LO-
WHT
LO+
YEL
SW1
SW2
(No.MA538<Rev.003>)18/19
CD PLAYER UNIT-2 LVA11003-05A (LVB11141-001A)(FLM-HC5-1D)
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
P2A
SW4
SW4
PbF
LVA11141-A2
(No.MA538<Rev.003>)19/19
PARTS LIST
CD RECEIVER
KD-R440J KD-R440JW KD-R441E
KD-R441EN KD-R441EU KD-R441EY
KD-R442E KD-R442EN KD-R442EY
KD-R443E KD-R443EN KD-R443EY
KD-R444UI KD-R445U KD-R445UN
KD-R446EU KD-R446U KD-R446UN
KD-R446UP KD-R446UT KD-R447EE
KD-R449E KD-R449EE KD-R449UR
KD-R540J KD-R541E KD-R541EN
KD-R541EY KD-R547EE
(No.MA538<Rev.003>)1/22
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS
z Due to the improvement in performance, some part numbers shown in the circuit diagrams
may not agree with those indicated in the Parts List.
z The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for
reference only.
z Since the circuit diagrams are standard ones, the circuits and circuit constants may be
subject to change for improvement without any notice.
■ PRECAUTIONS ON SERVICE
Certain parts of the power circuits and the GNDs differ according to the models. Care must be
taken for the following points as the differences are indicated separately in the LIVE GND ( ) and
the ISOLATED (NEUTRAL) GND ( ).
1. Do not touch the LIVE GND, or do not touch the LIVE GND and the ISOLATED (NEUTRAL)
GND at the same time. It may cause an electric shock.
Before pulling out the chassis or other parts, make sure to pull out the power cord from the
wall outlet first.
2. Do not short circuit between the LIVE GND and ISOLATED (NEUTRAL) GND, or never
measure the LIVE GND and ISOLATED (NEUTRAL) GND at the same time using measuring
instruments (oscilloscope, etc.). It may blow fuses or damage other parts.
(No.MA538<Rev.003>)2/22
EXPLODED VIEW (UNIT)
Block No.M1MM
239 235 x2
240
D
D
233
RC1 738
234
H 736 737
J x2 K
G
E x2
DC1
DC2
D
225 729 703 F
228
(ELECTRIC)
B KD-R441 , 442 , 443
740
227 E/EE/EN/EU/EY
226 KD-R447EE
505
701
223
KD-R540J FC1
208
C x2
209 204
A A
702
207
A
214
213 732
PA1 A 731
(SWITCH)
212
241
221
216
719
206
217
718
215
720 730
205
LCD1
222
711
210
Parts with the exploded numbers larger than 700 are not supplied.
No.MA538 created date:2013-02-18
(No.MA538<Rev.003>)3/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
(No.MA538<Rev.003>)4/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
K,L,P,U,W,Y,Z,AA,AB,
AC
241 GE40466-015A SPACER 1 A,B,M,N,O,P,Q,R,S,T,
V,W,X,Y,Z,AA,AB,AC
501 GET0829-001A INST BOOK ENG SPA FRE 1 A,B,Y
501 GET0832-001A INST BOOK ENG FRE 1 C,D,E,G,H,J,K,Z,AA
501 GET0830-001A INST BOOK ENG 1 M,N,Q
501 GET0830-005A INST BOOK INA 1 O,R
501 GET0830-001B INST BOOK ENG 1 P
501 GET0830-004A INST BOOK KOR 1 S
501 GET0919-001A INST BOOK 1 V
501 GET0902-001A INST BOOK POR 1 X
502 GET0832-002A INST BOOK DUT SPA ITA POR 1 C,G,J,Z
(No.MA538<Rev.003>)5/22
EXPLODED VIEW (CD MECHANISM: FLM-HC3-1D)
Block No.MBMM
JVG-31N 1
G332
JVS-1003 g
460
h
8
j
7 j
5
4
2
6
9 h
e
11
3
DM1
e
12
23
10
19
k
24
17
f
g
19
11.7mm ± 0.1mm
28
16
a f
27 18
D
901 (CD PLAYER) (2/2)
14
d
16 C
26 44 29 15
20 A
A
a a
43 22
K
42
21
42
13 B
G
K DPU1 F x2
d 25 G DM3 B
G
a b
38 DM2
FPC1 31 30
39
b 41
40 37
35 BOTTOM VIEW
H 12.7mm ± 0.1mm
901 (CD PLAYER) (1/2) 36
32 E x2
34
H
J SIDE VIEW
33
Parts with the exploded numbers larger than 900 are not supplied.
(No.MA538<Rev.003>)6/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
(No.MA538<Rev.003>)7/22
EXPLODED VIEW (CD MECHANISM: FLM-HC5-1D)
Block No.MCMM
JVG-31N 1
G332
JVS-1003 g
1771E
h
8
j
7 j
5
4
2
6
9 h
e
11
3
DM1
e
12
23
10
19
k
24
17
f
g
19
11.7mm ± 0.1mm
28
16
a f
27 18
D
901 (CD PLAYER) (2/2)
14
d
16 C
26 44 29 15
20 A
A
a a
43 22
K
42
21
42
13 B
G
K DPU1 F x2
d 25 G DM3 B
G
a b
38 DM2
FPC1 31 30
39
b 41
40 37
35 BOTTOM VIEW
H 12.7mm ± 0.1mm
901 (CD PLAYER) (1/2) 36
32 E x2
34
H
J SIDE VIEW
33
Parts with the exploded numbers larger than 900 are not supplied.
(No.MA538<Rev.003>)8/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
(No.MA538<Rev.003>)9/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
U,V,W,Y,Z,AA,AB,AC
15 LV36815-002A F WHEEL GEAR 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
16 LV36904-001A DAMPER 2 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
17 LV37061-001A DAMPER 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
18 LV45422-001A SUS SPRING(F) 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
19 LV45423-001A SUS SPRING(B) 2 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
20 LV38960-001A FEED RACK 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
21 LV36813-201A SUB GUIDE CAP 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
22 LV44555-001A MAIN SHAFT 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
23 LV38950-002A HC CL.BASE ASSY 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
24 LV45421-001A HC CL.SPRING 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
25 LV11686-003A BOTTOM FRAME 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
(No.MA538<Rev.003>)10/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
U,V,W,Y,Z,AA,AB,AC
44 LV45418-001A R.ARM SPRING 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
U,V,W,Y,Z,AA,AB,AC
(No.MA538<Rev.003>)11/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
(No.MA538<Rev.003>)12/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
C21 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C22 NCB31CK-105X C CAPACITOR 1uF 16V K 1
C23 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C24 QEKJ1CM-107Z E CAPACITOR 100uF 16V M 1
C26 NDC31HJ-471X C CAPACITOR 470pF 50V J 1
C27 NDC31HJ-2R0X C CAPACITOR 2pF 50V J 1 A,B,C,D,E,F,G,H,I,J,
K,L,U,V,W,X,Y,Z,AA,A
B,AC
C28 NDC31HJ-100X C CAPACITOR 10pF 50V J 1 A,B,X,Y
C100 NCB31HK-102X C CAPACITOR 1000pF 50V K 1 S
C101 NCB31CK-105X C CAPACITOR 1uF 16V K 1
C102 NCB31CK-105X C CAPACITOR 1uF 16V K 1
(No.MA538<Rev.003>)13/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
C559 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C561 NCB20JK-106X C CAPACITOR 10uF 6.3V K 1
C562 NCB20JK-106X C CAPACITOR 10uF 6.3V K 1
C564 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C565 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C566 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C567 NCB31AK-105X C CAPACITOR 1uF 10V K 1
C568 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C569 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C570 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C571 NDC31HJ-470X C CAPACITOR 47pF 50V J 1
C572 NCB31HK-153X C CAPACITOR 0.015uF 50V K 1
C573 NCB31HK-104X C CAPACITOR 0.1uF 50V K 1
C574 NCB31HK-103X C CAPACITOR 0.01uF 50V K 1
C576 NCB31HK-152X C CAPACITOR 1500pF 50V K 1
C581 NDC31HJ-471X C CAPACITOR 470pF 50V J 1
(No.MA538<Rev.003>)14/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
R1 NRSA63J-474X MG RESISTOR 470kΩ 1/16W J 1 M,N,O,P,Q,R,S,T
R2 NRSA63J-684X MG RESISTOR 680kΩ 1/16W J 1 A,B,C,D,E,F,G,H,I,J,
K,L,U,V,W,X,Y,Z,AA,A
B,AC
R2 NRSA63J-474X MG RESISTOR 470kΩ 1/16W J 1 M,N,O,P,Q,R,S,T
R3 NRSA63J-101X MG RESISTOR 100Ω 1/16W J 1 M,N,O,P,Q,R,S,T
R4 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J 1
R6 NRSA63J-221X MG RESISTOR 220Ω 1/16W J 1
R7 NRSA63J-221X MG RESISTOR 220Ω 1/16W J 1
R8 NRS181J-220X MG RESISTOR 22Ω 1/8W J 1
R9 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1 C,D,E,F,G,H,I,J,K,L,
M,N,O,P,Q,R,S,T,U,V,
W,Z,AA,AB,AC
R10 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1 M,N,O,P,Q,R,S,T
R12 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R101 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J 1
R111 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J 1
R112 NRSA63J-471X MG RESISTOR 470Ω 1/16W J 1
(No.MA538<Rev.003>)15/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
R444 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R445 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1
R447 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1 A,B,M,N,O,P,Q,R,S,T,
V,W,X,Y,Z,AA,AB,AC
R448 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R449 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1
R450 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R451 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R452 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1
R453 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
(No.MA538<Rev.003>)16/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
R575 NRS181J-332X MG RESISTOR 3.3kΩ 1/8W J 1
R576 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R577 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R595 NRSA63J-202X MG RESISTOR 2kΩ 1/16W J 1
R596 NRSA63J-202X MG RESISTOR 2kΩ 1/16W J 1
R701 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R702 NRSA63J-222X MG RESISTOR 2.2kΩ 1/16W J 1
R703 NRSA63J-911X MG RESISTOR 910Ω 1/16W J 1
R705 NRSA63J-222X MG RESISTOR 2.2kΩ 1/16W J 1
(No.MA538<Rev.003>)17/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
R784 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R786 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R787 NRS181J-223X MG RESISTOR 22kΩ 1/8W J 1
R789 NRSA63J-270X MG RESISTOR 27Ω 1/16W J 1
R790 NRSA63J-270X MG RESISTOR 27Ω 1/16W J 1
R791 NRS181J-0R0X MG RESISTOR 0Ω 1/8W J 1
R792 NRSA63J-0R0X MG RESISTOR 0Ω 1/10W J 1
R794 NRSA63J-300X MG RESISTOR 30Ω 1/16W J 1
R795 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R796 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J 1
R851 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J 1 M,N,O,P,Q,R,S,T
R881 NRSA63J-273X MG RESISTOR 27kΩ 1/16W J 1
(No.MA538<Rev.003>)18/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
X701 QAX0968-001Z CRYSTAL 1
X702 QAX0401-001 CRYSTAL 32.768KHz 1
SWITCH UNIT (GEA10344-xxA) <02>
IC603 TPS2065CDBV-X IC 1
IC661 PT16580-LQ IC 1
IC681 KSM-2003TN5B IR DETECT UNIT 1 A,B,M,N,O,P,Q,R,S,T,
V,W,X,Y,Z,AA,AB,AC
Q631 2SC6046-X TRANSISTOR 1 U,V,W,AC
Q632 2SC6046-X TRANSISTOR 1 A,B,C,D,E,F,G,H,I,J,
K,L,M,N,O,P,Q,R,S,T,
V,W,X,Y,Z,AA,AB,AC
Q633 LSCR523UB-X TRANSISTOR 1
D619 SML-D12P8W-X LED 1 U,V,W,AC
D620 SML-D12P8W-X LED 1 U,V,W,AC
D621 SML-D12P8W-X LED 1 U,V,W,AC
D622 SML-D12P8W-X LED 1 U,V,W,AC
D623 SML-D12P8W-X LED 1 U,V,W,AC
D624 SML-D12P8W-X LED 1 U,V,W,AC
D625 SML-D12P8W-X LED 1 U,V,W,AC
D626 SML-D12P8W-X LED 1 U,V,W,AC
D627 SML-D12P8W-X LED 1 U,V,W,AC
D628 SML-D12P8W-X LED 1 U,V,W,AC
D629 SML-D12P8W-X LED 1 U,V,W,AC
D630 SML-D12P8W-X LED 1 U,V,W,AC
D631 SML-D12P8W-X LED 1 U,V,W,AC
D632 SML-D12P8W-X LED 1 U,V,W,AC
(No.MA538<Rev.003>)19/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
D649 SML-311WT/JK/X LED 1 N,O
D650 SML-D12V8W-X LED 1 A,B,C,D,E,F,J,K,L,M,
P,Q,R,S,T,V,W,X,Y,Z,
AA,AB,AC
(No.MA538<Rev.003>)20/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
R639 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R639 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R640 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R640 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R641 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R641 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R642 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R642 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R643 NRS181J-122X MG RESISTOR 1.2kΩ 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R643 NRS181J-202X MG RESISTOR 2kΩ 1/8W J 1 G,H,I
R644 NRS181J-122X MG RESISTOR 1.2kΩ 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R644 NRS181J-202X MG RESISTOR 2kΩ 1/8W J 1 G,H,I
R645 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R645 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R646 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R646 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R647 NRS181J-431X MG RESISTOR 430Ω 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
N,O,P,Q,R,S,T,U,V,W,
X,Y,Z,AA,AB,AC
R647 NRS181J-681X MG RESISTOR 680Ω 1/8W J 1 G,H,I
R648 NRS181J-122X MG RESISTOR 1.2kΩ 1/8W J 1 A,B,C,D,E,F,J,K,L,M,
P,Q,R,S,T,U,V,W,X,Y,
Z,AA,AB,AC
(No.MA538<Rev.003>)21/22
MODEL MARK MODEL MARK MODEL MARK MODEL MARK
KD-R440J A KD-R440JW B KD-R441E C KD-R441EN D
KD-R441EU E KD-R441EY F KD-R442E G KD-R442EN H
KD-R442EY I KD-R443E J KD-R443EN K KD-R443EY L
KD-R444UI M KD-R445U N KD-R445UN O KD-R446EU P
KD-R446U Q KD-R446UN R KD-R446UP S KD-R446UT T
KD-R447EE U KD-R449E V KD-R449EE W KD-R449UR X
KD-R540J Y KD-R541E Z KD-R541EN AA KD-R541EY AB
KD-R547EE AC
Safe Symbol No. Parts No. Parts Name Description QTY Local
JS601 QSW1299-001 ROTARY ENCODER 1
LF691 NQR0536-001X CHOKE COIL 1
S601 NSW0246-001X TACT SWITCH 1
S602 NSW0246-001X TACT SWITCH 1
S603 NSW0246-001X TACT SWITCH 1
S604 NSW0246-001X TACT SWITCH 1
S605 NSW0246-001X TACT SWITCH 1
(No.MA538<Rev.003>)22/22