Professional Documents
Culture Documents
26
66. Neutral axis factor for m = 18, steel stress 1400 kg/ 75. The camber provided on a road is 1 : 25 for width of
cm2 and stress of concrete = 50 kg/cm2 for 1 : 2 : 4 7 m the difference of level across the road proper is
(a) - 0.35 (b) - 0.37 (a) 50 mm (b) 200 mm
(c) 0.39 (d) 0.41 (c) 100 mm (d) 150 mm
67. R.C.C. slab is to designed as a two way slab when L/ 76. If V is the speed of a moving vehicle, r is the radius of
B is less than the curve, q is the acceleration due to gravity, W is the
(a) 1.50 (b) 1.75 width of carriage way, the super elevation is expressed
(c) 2.00 (d) 2.25 as
68. A footing 1 m × 1 m in size rests on the surface of an WV WV
infinite layer of soil. It is subjected to a load of 600 kN. (a) (b)
gr gr 2
What is the immediate settlement of the soil by consid-
ering Eu = 2.0 MPa, N = 0.5 and influence factor = W 2V WV 2
0.95 ? (c) (d)
gr gr
(a) 22.5 mm (b) 25.5 mm
77. The suitable gradient, within an engineer must endeav-
(c) 27.5 mm (d) 213.7 mm
our to design the road is called
69. C.B.R. stands for
(a) Limiting gradient (b) Average gradient
(a) Central Bureau Regulation
(c) Fixed gradient (d) Ruling gradient
(b) Calcutta Bazar Rate
(c) California Bearing Ratio 1
78. If the coefficient of active earth pressure is , the
(d) Calicut - Bombay Roadways 3
70. In water bound macadam, the best consoli dation is coefficient or passive earth pressure with same value
achieved when the ratio of coarse aggregate and fine be
aggregate is 1
(a) 2 (b) 3
(a) 60 : 40 (b) 67 : 33 3
(c) 75 : 25 (d) 80 : 20 1 2
71. For all practical purpose, the field density of soil should (c) 3 (d) 3
3 3
be atleast ________ of proctor density. 79. The Plasticity Index of a particular soil is
(a) 80% (b) 90% (a) LL + Pl (b) PL - LL
(c) 85% (d) 95% (c) LL - Pl (d) PL / LL
72. Wide traverse survey is done accurately with 80. Which statement is correct ?
(a) Theodolite (a) Cohesion of a soil decreases as the moisture
(b) Prismatic compass content increase
(c) Dumpy level (b) Cohesion of a soil increases as the moisture
(d) Quick setting level content increase
73. Cement required in per m3 of concrete (Prop. 1 : 2 : (c) Cohesion of a soil decreases as the moisture
4) content decreases
(a) 280 kgs. (b) 300 kgs. (d) Cohesion of a soil decrease as the moisture
(c) 320 kgs. (d) 340 kgs. contents is nil
74. In an earthen embankment of NH of an height of 3.5m 81. Porosity (in percentage) of a soil mass is related to
with crest width of 12m and side slope 1 : 3, the earth void ratio V
required for 1km of road is
1 1V
(a) 42,000 m3 (b) 1,15,500m3 (a) (b)
1V 1V
(c) 60,000m3 (d) 78,750 m3
V V
(c) (d)
1V 1V
27
82. Consistency or Liquidity Index (LI) in% is defined as (c) Higher PH
W PL LL W (d) More inorganic chemicals
(a) (b) 91. Duty is said to be low when
Pl Pl
(a) Small amount of water is applied a small
LL PL PL W
(c) (d) area of land
Pl LL
(b) Small amount of water is applied a large
83. Grain size of silt (soil particles) according to I.R.C. is
area of land
(a) 2 to 0.2 mm
(c) Large amount of water is applied small
(b) 0.2 to 0.02 mm
area of land
(c) 0.02 to 0.002 mm
(d) Large amount of water is applied a large
(d) 0.002 to 0.0002 mm
area of land
84. Which is the greatest enemy of road ?
92. Canal fed from storage water grow
(a) Fire
(a) Algae (b) Plants
(b) Water content increase
(c) Weeds (d) Acid
(c) Cohesion of a soil decreased as the
93. Dug wells are used in
moisture content decrease
(a) Unconfined aquifers
(d) Cohesion of a soil decreases as the
(b) Confined aquifer
moisture content is nil
(c) Aquitand
85. The scale or drawing required for approval by corpo-
(d) Aquiclude
ration for place and elevation of residential building.
94. Plot of run off vs. time is known as
(a) 1 : 25 (b) 1 : 50
(a) Hydrograph (b) Unit hydrograph
(c) 1 : 100 (d) 1 : 500
(c) Hyetograph (d) Mass curve
86. The isometric view of a three dimensional object the
95. Delta for crop with Duty 1728 hectare per cumec
value of the angle with horizontal is usually.
and base period 120 days is
(a) 15o (b) 20o
(a) 120 cm (b) 100 cm
1o (c) 90 cm (d) 60 cm
(c) 25 o
(d) 33
3 96. When a drain passed over a canal, the structure pro-
87. Theoretical velocity with respect to head (H) of water vided is known as
or pressure is taken as (a) Aqueduct
(b) Super passage
V2 V
(a) (b) (c) Canal syphon
2g 2g
(d) Syphon aqueduct
2V V 97. A slow sand filter is suitable
(c) (d)
g g (a) Where land is available at reasonable rate
88. Best quality stone chips at Kolkata is available from (b) Where land is costly
(a) Naihati (b) Rampurhat (c) Where filter rate is very high
(c) Pakur (d) Panchami (d) In a metropolitan city
89. Total hardness or water is expressed as 98. Weep Holes are provided in all abutment and wing
(a) H2SO4 (b) HCO3 walls to prevent pressure due to
(c) CaCO3 (d) CaCO2 (a) Earth (b) Sand
90. Deep wells contains (c) Clay (d) Water
(a) High concentration of minerals 99. Yield point is the point, where the elangation under
(b) High concentration of lime (a) Tension decreases without increases of
28
load
(b) Compression increases without increases
of load
(c) Compression decreases without increases
of load
(d) Tension increases without increases of
load
100. The maximum Bending Moment is sometime called the
29