Professional Documents
Culture Documents
Home
NanoVNA-F Quick start guide - Firmware 0.1.x Date: 3 Feb 2020
Release: 2.0
Menu
DISPLAY TRACE Select a trace to modified the format, scale and so on TRACE 0 SELECT
MARKER FORMAT LOGMAG TRACE 1 OFF
STIMULUS SCALE SCALE/DIV PHASE TRACE 2
S11 REFERENCE
CAL CHANNEL REFLECT POSITION
DELAY TRACE 3
S21 ELECTRICAL
RECALL TRANSFORM
THROUGH DELAY
SMITH < BACK POLAR
CONFIG < BACK < BACK < BACK SWR LINEAR
> MORE REAL
TOUCH CAL RECALL 0 < BACK IMAG
SELECT
TOUCH TEST RECALL 1 MARKER
RESISTANCE
Keypad
SAVE RECALL 2 SEARCH MAXIMUM REACTANCE
S
deepelec.aliexpress.com PAUSE VELOCITY
DELTA MAXIMUM
T github.com/flyoob/NanoVNA-F SWEEP FACTOR
X groups.io/g/nanovna-f < BACK Keypad < BACK < BACK < BACK
START 50.000 kHz STOP 1000.000 000 MHz SAVE SAVE 0 SHORT SAVE 0
RESET SAVE 1 LOAD SAVE 1 7 8 9 G
If calibration is available, the CAL status will be displayed. CORRECTION SAVE 2 ISOLN SAVE 2
Otherwise, it is hidden. C * is in the state where an unsaved calibration is < BACK SAVE 3 THRU SAVE 3 4 5 6 M
Done
applied(it disappears from memory when the power is turned off).
SAVE 4 DONE SAVE 4
C0 to C4 Indicates that the saved calibration values are applied to one < BACK < BACK < BACK 1 2 3 k
of the save locations. Saved or Unsaved will change when calibration
data is properly saved. Deepelec Store
Status
charging
Red
Blink
Blue
OFF
After turning off
the power, the
0 . ← x1
The letters below C indicate that the following
Charge blue light stays on
error terms have been applied. full ON OFF for about 40
Backspace & Exit
D: Directivity, R: Reflection Tracking, discharging OFF ON seconds, and then
S: Source Match, T: Transmission Tracking and X: Isolation Discharge goes out.
low battery OFF Blink