Professional Documents
Culture Documents
Pyrocrete 241 HY - MSDS
Pyrocrete 241 HY - MSDS
2. Hazard Identification
Carcinogenicity, category 1A
STOT, single exposure, category 3, RTI
Skin Corrosion, category 1
Skin Sensitizer, category 1
Page 1 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
Symbol(s) of Product
Signal Word
danger
Skin Corrosion, category 1 H314-1 Causes severe skin burns and eye damage.
Skin Sensitizer, category 1 H317 May cause an allergic skin reaction.
STOT, single exposure, category 3, RTI H335 May cause respiratory irritation.
Carcinogenicity, category 1A H350-1A May cause cancer.
GHS PRECAUTION PHRASES
P201 Obtain special instructions before use.
P202 Do not handle until all safety precautions have been read
and understood.
P260 Do not breathe dust/fume/gas/mist/vapours/spray.
P264 Wash hands thoroughly after handling.
P280 Wear protective gloves/protective clothing/eye protection/
face protection.
P284 Wear respiratory protection.
P302+352 IF ON SKIN: Wash with plenty of soap and water.
P303+361+353 IF ON SKIN (or hair): Remove/Take off immediately all
contaminated clothing. Rinse skin with water/shower.
P304+340 IF INHALED: Remove victim to fresh air and keep at rest in a
position comfortable for breathing.
P308+313 IF exposed or concerned: Get medical advice/attention
P333+313 If skin irritation or rash occurs: Get medical advice/attention.
2.3 Other hazards
No Information
3. Composition/Information On Ingredients
3.2 Mixtures
Hazardous Ingredients
CAS-No. Chemical Name %
65997-15-1 PORTLAND CEMENT 25-50
12001-26-2 MICA 10-25
93763-70-3 AMORPHOUS SILICATE 2.5-10
1317-65-3 LIMESTONE 2.5-10
7778-18-9 GYPSUM / CALCIUM SULFATE DIHYDRATE 1.0-2.5
1305-78-8 CALCIUM OXIDE 1.0-2.5
1309-48-4 MAGNESIUM OXIDE 1.0-2.5
1344-09-8 SODIUM SILICATE 1.0-2.5
14808-60-7 MICROCRYSTALLINE SILICA 0.1-1.0
Page 2 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
Additional Information: The text for GHS Hazard Statements shown above (if any) is given in Section 16.
4. First-aid Measures
4.1 Description of First Aid Measures
AFTER INHALATION: Remove person to fresh air. If signs/symptoms continue, get medical attention.
AFTER SKIN CONTACT: Wash off with soap and plenty of water.
AFTER EYE CONTACT: Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.
AFTER INGESTION: Do NOT induce vomiting. Never give anything by mouth to an unconscious person. If swallowed, call
a poison control centre or doctor immediately.
4.2 Most important symptoms and effects, both acute and delayed
Irritating to respiratory system. This product contains silica which is classified by IARC as a known human carcinogen (Group
1). Crystalline silica is known to cause silicosis.
4.3 Indication of any immediate medical attention and special treatment needed
No Information
5. Fire-fighting Measures
5.1 Extinguishing Media:
Carbon Dioxide, Dry Chemical, Foam, Water Fog
UNUSUAL FIRE AND EXPLOSION HAZARDS: No Information
Use personal protective equipment. Sweep up to prevent slipping hazard. Forms slippery/greasy layers with water.
6.2 Environmental precautions
No Information
6.3 Methods and material for containment and cleaning up
No Information
6.4 Reference to other sections
No Information
INSTRUCTIONS FOR SAFE HANDLING : Avoid breathing dust. Do not breathe vapours or spray mist. Wash thoroughly
Page 3 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
No Information
Name % ACGIH TLV- ACGIH TLV- OSHA PEL- OSHA PEL- OEL Note
TWA STEL TWA CEILING
PORTLAND CEMENT 25-50 10 MG/M3 N/E 5 MG/M3 N/E
MICA 10-25 3 MGM3 N/E 3 MGM3 N/E
AMORPHOUS SILICATE 2.5-10 10 MGM3 NE 5 MGM3 NE
LIMESTONE 2.5-10 N/E N/E 5 MGM3 N/E
GYPSUM / CALCIUM SULFATE DIHYDRATE 1.0-2.5 N/E N/E N/E N/E
CALCIUM OXIDE 1.0-2.5 2 MGM3 N/E 5 MGM3 N/E
MAGNESIUM OXIDE 1.0-2.5 N/E N/E N/E N/E
SODIUM SILICATE 1.0-2.5 N/E N/E N/E N/E
MICROCRYSTALLINE SILICA 0.1-1.0 0.025 MG/M3 N/E 0.1 MG/M3 N/E
(respirable) (respirable)
FURTHER INFORMATION: No Information
Page 4 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
Page 5 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
Irritation: Unknown
Corrosivity: Unknown
Sensitization: Unknown
Carcinogenicity: Unknown
Mutagenicity: Unknown
If no information is available above under Acute Toxicity then the acute effects of this product have not been tested.
Data on individual components are tabulated below:
1317-65-3 LIMESTONE 6450 mg/kg, oral, rat Not Available Not Available
Additional Information:
Irritating to respiratory system. This product contains silica which is classified by IARC as a known human carcinogen (Group 1).
Crystalline silica is known to cause silicosis.
Page 6 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
12.5 Results of PBT and vPvB The product does not meet the criteria for PBT/VPvB in accordance with Annex XIII.
assessment:
Page 7 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
Chemical Name CAS-No.
No TSCA 12(b) components exist in this product.
U.S. State Regulations: As follows -
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
The following non-hazardous ingredients are present in the product at greater than 3%.
No Information
Page 8 / 9
Date Printed: 12/12/2016 Product: 0298S7NL
The information contained herein is, to the best of our knowledge and belief accurate. However,
since the conditions of handling and use are beyond our control, we make no guarantee of results,
and assume no liability for damages incurred by use of this material. It is the responsibility of
the user to comply with all applicable federal, state, and local laws and regulations.
Page 9 / 9