Professional Documents
Culture Documents
• A code gives the acceptance standard for excess weld metal ‘h’ as h
≤ 1mm +0. 1b. max. 5mm; where ‘b’ is the width of the weld cap. For
which of the following situations is the excess weld metal
acceptable?
• b = 15; h =3.0
• b = 20; h =3.0
• b = 28; h = 4.0
• b = 40; h = 5.4
• 580-620°C
• 5000-6200°C
• 75-80°C
• 1500-1800°C
• Approximately 200°C
• Approximately 600°C
• Approximately 900°C
• Approximately 1200°C
• The typical included angle used for MMA welding of a 15MM thick
steel single V butt joint is most likely to be:
• 35°
• 120°
• 70°
• 90°
• A transverse tensile test peace from a weld joint will give the:
• Radiographic testing
• Ultrasonic testing
• Curies
• KV
• IQI values
• Aluminum alloys
• Carbon steels
• Copper
• Weldments in carbon-manganese steels, made by low heat input
welding may show
• greater ductility
• higher distortion
• higher dilution
• higher hardness
• Excessive distortion
• Weld decay
• Formation of iron-sulphides
• In the MAG welding process which gas type gives good penetration
but an unstable arc high levels of spatter?
• Pure argon
a. basic type
b. Cellulosic type
c. Rutile type
• Agglomerated
• Fused
• Basic
• Neutral
• 35 joules @ +30°C
• Basic-covered
• Cellulosic covered
• Rutile covered
• Current is to low
• Which of the following imperfection types is NOT usually associated
with TIG welding?
• Tungsten inclusions
• Cater pipe
• Spatters
• WPS
• PWPS
• sWPS
• pWPT
• AC
• DC electrode negative
• DC electrode positive
• Travel speed
• Welding current
• Arc length
• Inductance
• Constant current
• Dropping
• Raising
• Friction welding
• Resistance welding
• Laser welding
• BS EN ISO 2560
• BS EN 15614
• BS EN ISO 22553
• BS EN 287
a.a5 b. t5 c. z5 d. 5z